Abstract:Microscale boiling heat transfer experiments were performed using acetone as the working fluid in ten parallel silicon microchannels with hydraulic diameters of 155.4 mum. An infrared radiator image system is used for the chip temperature measurements, while an optical system combining a microscope and a high-speed camera is used for transient flow pattern identification. By covering the present data range it is found that all microchannels repeat the transient flow patterns in a timescale of milliseconds while the fluid pressures/temperatures are stable. A full cycle can be subdivided into three substages: liquid refilling stage, bubble nucleation, growth and coalescence stage, and transient annular flow stage. Correspondingly four flow patterns are identified. Paired or triplet bubbles are observed to be nucleated and grow up simultaneously in, or very close to, the channel corners at the same cross section. The nucleated bubbles experience several milliseconds of growth until coalescence takes place. Then a single liquid plug is separated into two parts, which are pushed out of the flow field view in less than 1 ms. In the transient annular flow stage, the liquid films that are drawn into the comers of the channel become less and less versus time. Once a partially or fully dried-out state is reached, all the microchannels are refilled with fresh liquid and a new cycle begins. The probabilities of each flow pattern occurring and the liquid refilling follow the statistical principle well. The measured chip temperatures are not uniform across the whole heating area, attributed to the uneven liquid refilling probabilities for different channels and the uneven possibilities that are immersed in the liquid for different heating regions. The chip temperatures display spatial variation behavior in the majority of the heating area, due to the liquid and vapor alternatively passing through the microchannels. To the authors' knowledge, some of the above experimental findings have not been previously reported.

&Lt;title>thermocapillary Flow in a Thin Annular Pool of Silicon Melt</title>

Laminar mixed convection heat transfer of SiC-EG nanofluids in a triangular enclosure with a rotating inner cylinder: simulations based on the measured thermal conductivity and viscosity

Close-contact Melting of Shear-Thinning Fluids

Visualization of Flow and Temperature Fields of Natural Convection in a Hemisphere Heated from Below.

Linear stability analysis on the thermocapillary flow of molten silicon in a liquid bridge between unequal disks under a rotating magnetic field

Fundamental Effects in Nanoscale Thermocapillary Flow

Effect of rotating magnetic field on instabilities of thermocapillary flow in a Czochralski silicon melt pool

The influence of surface deformation on thermocapillary flow instabilities in low Prandtl melting pools with surfactants

Natural Convection in a Horizontal Silicone Oil Layer in a Circular Cylinder Heated from below and Cooled from Above.

Flow Boiling in Vertical Narrow Microchannels of Different Surface Wettability Characteristics

Visual Study of Flow Pattern Evolution of Flow Boiling in A Microtube

Microscale Boiling Heat Transfer in A Micro-Timescale at High Heat Fluxes

Flow pattern-based heat transfer analysis of microchannel flow boiling: An experimental investigation

Effect of volume ratio on thermocapillary convection in annular liquid pools in space

Interfacial Wave Behavior and Its Effect on the Flow and Condensation Heat Transfer in a Microtube

Flow instabilities in thermocapillary liquid bridges between two coaxial disks with different radii

Numerical analysis of thermohydraulic behavior in a directional solidification furnace

Experimental Study Of Saturated Flow Boiling In Vertical Narrow Microchannel

Thermoelectrohydrodynamic convection in a finite cylindrical annulus under microgravity

Flow Boiling in Microchannels Enhanced by Parallel Microgrooves Fabricated on the Bottom Surfaces

Flow Boiling Heat Transfer in A Minichannel with Enhanced Heating Surface

&Lt;title&gt;thermocapillary Flow in a Thin Annular Pool of Silicon Melt&lt;/title&gt;