Abstract:Abstract The high-speed on/off valve (HSV) is the core component of a digital hydraulic system. Current research mainly focuses on single coil spool-type HSVs, with limited investigation into coil optimization for multi-coil integrated HSVs. Developing high-performance HSVs with integrated multi-coils presents ongoing challenges, particularly in achieving low temperature rise, rapid response, and controllability. To address these challenges, this study proposes an optimization method for the integrated HSVs, harmonized with voltage control strategies to augment dynamic performance within digital valve systems. The investigation introduces a multi-coil integrated digital hydraulic valve and delves into the functional correlations among coil volume, temperature rise, and input power through both simulation and experimental methods. Leveraging multi-objective optimization techniques rooted in meta model of optimal prognosis (MOP) and evolutionary algorithm (EA), the design methodology refines the valve winding. The simulation results demonstrate that, firstly, under temperature rise constraints, coils designed with a four-voltage control strategy, compared to those developed based on single and three-voltage control strategies, will experience a reduction in opening time by 50% (from 2.0ms to 1.0ms) and 71.4% (from 3.5ms to 1.0ms), respectively, even if a four-voltage control strategy is applied subsequently. Secondly, if a single voltage control strategy is adopted for coils optimally designed based on three or four-voltage control strategies, the coil temperature may exceed the allowable limit, leading to coil burnout. Finally, regardless of the voltage control strategy used to obtain the coils, subsequent adoption of the three voltage control strategy results in the lowest coil temperature rise.

Water Hammer Suppression with Variable Terminal Time via PDE-Constrained Dynamic Optimization

Water hammer mitigation via PDE-constrained optimization

Optimal boundary control for water hammer suppression in fluid transmission pipelines

Time-delayed stochastic optimal control of strongly non-linear systems with actuator saturation by using stochastic maximum principle

Stochastic Optimal Bounded Control of Mdof Quasi Nonintegrable-Hamiltonian Systems with Actuator Saturation

Stochastic minimax semi-active control for MDOF nonlinear uncertain systems under combined harmonic and wide-band noise excitations using MR dampers

Stochastic Optimal Bounded Control for MDOF Nonlinear Systems under Combined Harmonic and Wide-Band Noise Excitations with Actuator Saturation

Stabilizing Model Predictive Control Scheme for Piecewise Affine Systems with Maximal Positively Invariant Terminal Set

Optimization of Integrated High-Speed On/Off Valve Aligned with Voltage Control Strategies for Enhanced Dynamic Performance in Digital Hydraulic Systems

Dual-objective optimization strategy of self-adaptive transient pressure controller in water delivery engineering

Three-dimensional computational fluid dynamics simulation of valve-induced water hammer

Dynamic Analysis and Improvement of the Electrohydraulic System under Power Limitation Control.

Dynamic Interaction Between Valve-Closure Water Hammer Wave and Centrifugal Pump

A Control Method to Balance the Efficiency and Reliability of a Time-Delayed Pump-Valve System

Sensitivity Analysis of Operational Time Differences for a Pump–Valve System on a Water Hammer Response

Mixed-Integer Path-Stable Optimisation, with Applications in Model-Predictive Control of Water Systems

A Bounded Stochastic Optimal Semi-Active Control

Axisymmetric Weakly Compressible Transient Pipe Flow and Water Hammer Control

Approximation of the non-linear water hammer problem by a Lax-Wendroff finite difference scheme

Dynamic Impact of Hydraulic Systems Using Pressure Feedback for Active Damping

Study on optimal water hammer protection for high-head and multi-undulation water conveyance system and empirical formulae for pressure head at nodes