Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

Local Corrosion Behavior of Pipeline Steel under Deposition Layer in Produced Water of Alkali/ Surfactants/ Polymers

The effect of CaCO 3 deposit on corrosion of NaCl - Alkali/ surfactant/ polymer produced water pipeline

Corrosion Behavior of Carbon Steel Pipelines under Different Deposits in Oil and Gas Transportation

Effect of salt-resistant polymer flooding system SRB on corrosion behavior of 20# carbon steel under deposition

Electrochemical Study on the Macro-Cell Corrosion of Pipeline Steel Partially Covered by Different Kinds of Mineral Deposits

Study on Under-Deposit Corrosion Behavior of X65 Steel in Simulated CO2 Saturated Produced Water

Corrosion Behavior on 20# Pipeline Steel by Sulfate-Reducing Bacteria in Simulated NaCl Alkali/Surfactant/Polymer Produced Solution

Corrosion Behavior of Pipeline Steel Welds in Simulated Produced Water with Different Co2 Partial Pressures under High Temperature

Role of Fe oxide in the underdeposit corrosion of pipeline steel in oilfield produced water containing SRB

Corrosion behavior of X80 pipeline steel local defect pits under static liquid film

Effect of oil displacement agent on corrosion behavior of NaCl - Alkali/ surfactant/ polymer flooding pipeline steel

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Localized corrosion of carbon steel in a CO2-saturated oilfield formation water

Corrosion Behavior of Low‐alloy Steel Used for Pipeline at Vapor‐saturated CO2 and CO2‐saturated Brine Conditions

Corrosion Behavior of Low Alloy Pipeline Steel in Saline Solution Saturated with Supercritical Carbon Dioxide

Research on Pipeline Internal Wall Flow-induced Corrosion Behavior in Oil Well Produced Water Medium

Corrosion Behavior of Pipeline Steel in Oilfield Produced Water under Dynamic Corrosion System

Corrosion Behavior of X80 Pipeline Steel in Alkaline Sand Soil with Saturated Water

Effect of Main Controlling Factor on the Corrosion Behaviour of API X65 Pipeline Steel in the CO2/oil/water Environment

Study on corrosion properties of pipelines in simulated produced water saturated with supercritical CO2

Corrosion Behavior of Low-Alloy Pipeline Steel Exposed to H2S/CO2-Saturated Saline Solution