Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Numerical Simulation of Interaction Unsteady Flows Around Co-Axial Rotors in Hover

Numerical Simulation and Aerodynamic Investigation of the Intermeshing Rotor in Hover

Experimental Study to Quantify the Rotor-to-Rotor Interaction Characteristics of a Small Unmanned-Aerial-Vehicle

Numerical Study on Interactional Aerodynamics of a Quadcopter in Hover with Overset Mesh in OpenFOAM

Aerodynamic interference and unsteady loads for a hovering intermeshing rotor

Numerical analyses of aeroacoustic characteristics of tiltrotor considering the aerodynamic interaction by the fuselage in hover

Aerodynamic Simulation of a Typical Multirotor e VTOL Aircraft Configuration.

Validation of Higher-Order Interactional Aerodynamics Simulations on Full Helicopter Configurations

Numerical Investigation of Aerodynamic Interactions for the Coaxial Rotor System in Low-Speed Forward Flight

High-fidelity numerical investigations of rotor-propeller aerodynamic interactions

Aerodynamic interference analysis and modeling of heterogeneous rotors

Actuator Surface Modeling of Rotors at the Ship–Helicopter Dynamic Interface

A New Way of Simulating the Flow Field of a Lifting Rotor in Hover

Numerical Simulation Study on the Interaction Between a Gravity Current and Horizontal Cylinders

Numerical Investigation of Airfoilrotor Interaction at Low Reynolds Number

Rotor interactional effects on aerodynamic and noise characteristics of a small multirotor unmanned aerial vehicle

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

Numerical Simulation on the Inviscid Flowfield of Transonic Hovering Rotor Using Implicit Method and WENO Schemes

Investigation on Aerodynamic Noise Characteristics of Coaxial Rotor in Hover

Numerical analysis of rotor aeroacoustic characteristics during collective pitch aperiodic variation in hover

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor