Abstract:ACCURATE simulation of the viscous flow around a helicopter rotor is still a challenging problem. To predict the blade loading accurately, the numerical method must have a capability to capture the vortical wake generated from the rotor blade tip precisely, which significantly affects the aerodynamic performance of the rotor. Therefore, both the numerical scheme with low numerical dissipation and sufficient dense mesh far away from the blade surface are required for rotor computations to simulate the tip vortex with minimal distortion. Furthermore, for a hovering case, a large numerical integration time is needed for the capture of the fully developed vortical wake [1]. In addition, the existence of incompressible flow near the root will also make the convergence slow. Compared with fixed-wing computations, hovering rotor computations not only require more accurate numerical scheme but also will take much more run time to converge. During the past two decades many numerical methods [2–7] have been developed to simulate the viscous flow around a hovering rotor. The methods [2,3] with the single-block structured grid suffer from the grid-quality problem, because the mesh must be stretched and skewed to cover the complete computational domain and to match the periodic boundary condition. To avoid this problem, the chimera technique [4–7] suggested by Benek et al. [8] was introduced into hovering rotor computations. To capture the tip vortex without unphysical distortion and predict the blade loading accurately, some high-order schemes and vortex-adapted chimera methods [6,7] were presented. Although significant advances in the accurate simulation of the tip vortex have been made with these advanced methods, the large computation cost and the low robustness, as well as the complexity make them far away from engineering applications. As mentioned above, hovering rotor computations, especially the computations with high-order methods, require more run time to converge than their fixed-wing counterparts. A few attempts [1,9,10] have been made to use multigrid methods to accelerate the convergence of hovering rotor calculations. Up to now, there is few works concerning the multigrid method for the viscous flow computation about a hovering rotor based on overset grids. The main objective of the present study is to develop an efficient multigrid algorithm coupled with chimera grids for Navier–Stokes computations about a hovering rotor. It should be mentioned that the experience of this work can be extended to accelerate the computation about a rotor in forward flight using moving overset grids,which is themainmotivation of this research. Furthermore, this experience can also be the basis of the future multigrid computation using high-order methods and chimera grids for rotor flows.

A New Way of Simulating the Flow Field of a Lifting Rotor in Hover

Navier-Stokes computation about a helicopter rotor in hover using chimera grids and multigrid acceleration

Numerical Simulation and Aerodynamic Investigation of the Intermeshing Rotor in Hover

Multigrid Acceleration and Chimera Technique for Viscous Flow Past a Hovering Rotor

Euler solutions of transonic flow for a helicopter rotor in hover using multigrid method

Numerical simulation of internal flow in forward-curved centrifugal fan

Numerical Simulation on the Inviscid Flowfield of Transonic Hovering Rotor Using Implicit Method and WENO Schemes

Efficient Numerical Techniques for Simulating a Rotorcraft Flow Field with Overlapping Grids

Transonic Hovering Rotor Aeroacoustic Predictions Using Navier-Stokes/Kirchhoff Method

Numerical Study on the Vortex Motion Patterns Around a Rotating Circular Cylinder and Their Critical Characters

The mutilgrid method in Euler equation computation about a helicopter rotor in hover

Aerodynamic Simulation of a Typical Multirotor e VTOL Aircraft Configuration.

Simulating Unsteady Aerodynamics of Helicopter Rotor with Panel/viscous Vortex Particle Method

High Effective WENO Scheme for Transonic Inviscid Flow Computation on a Helicopter Rotor in Hover

Direct numerical simulation of the turbulent flow around a Flettner rotor

Combination of Advanced Actuator Line/Disk Model and High-Order Unstructured Finite Volume Solver for Helicopter Rotors

Highly Efficient Unsteady Panel Time-Marching Free Wake for Aerodynamics of Rotorcraft

A High Efficiency Method for Calculating the Aeroacoustic Noise of Transonic Rotors

Panel/full-span Free-Wake Coupled Method for Unsteady Aerodynamics of Helicopter Rotor Blade

Numerical simulation of the horizontal rotating cylinder and the air entrainment near the free surface

Simulation research on micro-cavity flow field characteristics of liquid floating rotor gyro