Abstract:Supercritical cryogenic fluids are widely used in thermal equipment for liquid air energy storage (LAES), hypersonic aircraft, liquid hydrogen, etc. Unstable flow of supercritical fluids can cause thermal fatigue, mechanical vibration, noise, etc. In this work, a cryogenic heat transfer system was established to study the flow instability characteristics of supercritical nitrogen (SN2) in a vertical tube. The dynamic unstable flow of density-wave oscillation was captured in the experimental system. The oscillation amplitude of wall temperature is more than 100 K and the temperature peak can reach 150% of Tave. Based on the pseudo-two-phase model, the effect of several key parameters was analyzed. Unstable flow is prone to occur when the outlet state is located in the two-phase-like (TPL) region with dramatic changes in physical properties. The outlet state can be kept away from the TPL region by two approaches. One is to locate the outlet in the vapor-like (VL) region by increasing the heat flux, decreasing the mass flux, and increasing the inlet temperature; the other one is to locate the outlet in the liquid-like (LL) region by decreasing the heat flux, increasing the mass flux, and decreasing the inlet temperature. When Pin is close to Pc, the TPL region is extremely narrow, and the outlet state is easily located in the VL region. The dimensionless p-h diagram is proposed to divide the unstable flow region of supercritical fluids. Unstable flow occurs in the region where the outlet dimensionless enthalpy (NSPCO) is located between the VL boundary (NSPCO_V) and the LL boundary (NSPCO_L). The analysis of flow instability characteristics and the proposed prediction methods can provide a basis for the system design of supercritical cryogenic fluids.

Study of thermoacoustic oscillations in half-open tubes for saturated superfluid helium

CFD Simulation of Thermoacoustic Oscillations in Liquid Helium Cryogenic System

Performance Comparison of Thermoacoustic Engine with Gas-Liquid and Gas Oscillation

Numerical Study on Suppression of Thermoacoustic Oscillation in Cryogenic Helium Pipeline System

Basic Analysis on a Thermoacoustic Engine with Gas and Liquid

Numerical Study of Oscillation Characteristics in T-shaped Cryogenic Helium Tube

Study on the onset and damping process of a thermoacoustic stirling prime mover

Discussion on resonant frequency in thermoacoustic systems

Investigation on Transient Process of Thermoacoustic Oscillation in a Gas–liquid Standing-Wave Thermoacoustic Engine

Identification of Nonlinear Characteristics of Thermoacoustic Oscillations in Helium Piping Systems

Characteristics study on the oscillation onset and damping of a traveling-wave thermoacoustic prime mover

Experimental observation on a small-scale thermoacoustic prime mover

STUDY ON A THERMOACOUSTICALLY DRIVEN PULSE TUBE REFRIGERATOR OPERATING AT 124K

Numerical Investigation on the Control of Cryogenic Fluid Oscillations by Applying an External Sound Source

Study on Cooling Capacity Characteristics of an Open-Cycle Joule-Thomson Cryocooler Working at Liquid Helium Temperature

EXPERIMENTAL STUDY ON SINGULAR TEMPERATURE PROFILES IN A TUBE TO PERIODICAL HEATING AT END

Thermoacoustic Streaming in a Tube with Isothermal Outer Surface

Experimental Study of Quasi-Periodic On-off Phenomena in a Small-Scale Traveling Wave Thermoacoustic Heat Engine

Experimental Study and Prediction of Flow Instability of Supercritical Nitrogen in a Vertical Upward Tube

Study of periodicity impact of helium turbine of superconducting Tokamak device

Transient Measurement of Temperature Oscillation During Noisy Film Boiling in Superfluid Helium Ii