Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Implementation of the Filtered Turbulent Flame Model in Non-premixed Combustion Simulation

Non-premixed Turbulent Combustion Modeling Based on the Filtered Turbulent Flamelet Equation

Large Eddy Simulation/dynamic Thickened Flame Modeling of a High Karlovitz Number Turbulent Premixed Jet Flame

Low Mach number lattice Boltzmann model for turbulent combustion: flow in confined geometries

Numerical Investigation of Swirl-Stabilized Pulverized Coal Flames in Air and Oxy-Fuel Atmospheres by Means of Large Eddy Simulation Coupled with Tabulated Chemistry

Modeling of Supercritical-Pressure Turbulent Combustion of Hydrocarbon Fuels Using A Modified Flamelet-Progress-Variable Approach

Large-eddy simulation of methane/air non-premixed combustion using dynamically full thickened flame model

Large Eddy Simulation of Turbulent Premixed Swirling Flames Using Dynamic Thickened Flame with Tabulated Detailed Chemistry

On the Modeling of Scalar Mixing Timescale in Filtered Density Function Simulation of Turbulent Premixed Flames

Filtered Density Function Simulations of a Near-Limit Turbulent Lean Premixed Flame

An Improved NO Prediction Model for Large Eddy Simulation of Turbulent Combustion

Evaluation of the wall heat flux in filtered premixed turbulent combustion

Large Eddy Simulation of Soot Formation in a Turbulent Lifted Flame with a Discretized Population Balance and a Reduced Kinetic Mechanism

Dynamic Modelling of Subgrid Scalar Dissipation Rate in Premixed and Partially Premixed Flames with Differential Filter

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Simulations of a turbulent non-premixed flame using combined dimension reduction and tabulation for combustion chemistry

Large eddy simulation of partially premixed flames with inhomogeneous inlets based on the DTF combustion model

Simulation of Turbulent Non-Premixed Flames Influenced by Buoyancy

Large-eddy Simulation of Turbulent Combustion Based on Steady Flamelet/progress Variable Approach

Differential Diffusion Modeling in LES/FDF Simulations of Turbulent Flames

Towards large eddy simulations of premixed turbulent flames without a combustion model