Abstract:This article proposes a novel ultralow specific ON-resistance (${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ ) triple reduced surface field (RESURF) lateral double-diffused MOSFET (LDMOS) with sandwich n-p-n layer. Compared with the conventional triple RESURF LDMOS with n-type top layer (NTTR LDMOS), the new structure is characterized by an additional N-buried layer below the P-buried layer. Due to the introduction of N-buried layer, the concentration of N-top layer will decrease to ensure charge balance, thus making the surface electric field distribution better and the higher additional doping introduced by N-top and N-buried layers can be achieved. The dose and implantation energy of n-p-n layers were simulated and optimized. Furthermore, in order to eliminate the premature avalanche breakdown occurring in the source-centered termination region, substrate termination technology (STT) is applied to avoid the high electric field peaks generated in the curved source region with small curvature radius. But the use of STT makes it easy to breakdown in the transitional region compared with the straight region. Therefore, the transitional region is studied and the crucial parameter $\Delta {L}$ in the layout of transitional region is also optimized. The fabricated device experimentally demonstrated improved performance with low ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ of 78.3 $\text{m}\Omega \cdot $ cm2 and high breakdown voltage (BV) of 795 V, and the experimental ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ is 26.8% lower than that of the conventional triple RESURF LDMOS (CTR LDMOS) and 10% lower than that of the NTTR LDMOS based on ${L}_{d} = 67 \mu \text{m}$ , which can break the silicon limit of CTR and NTTR LDMOS and meet the demand of 700-V high-voltage integrated circuit applications.

An Ultralow Specific On-Resistance Bidirectional Trench Power MOSFET with RESURF Stepped Oxide

Ultralow Specific On-Resistance High Voltage Trench Soi Ldmos with Enhanced Resurf Effect

A Novel Ultralow RON,sp Triple RESURF LDMOS with Sandwich N-P-n Layer

A Novel Ultralow R ON,sp Triple RESURF LDMOS With Sandwich n-p-n Layer

Ultra-Low On-Resistance SiC LDMOS With Separated-Protected Trench Gates and Trench RESURF Technology

High Density Bidirectional Lithium Ion Battery Disconnect Switch with Ultralow Specific On-Resistance

A Low Specific on-Resistance SOI Trench MOSFET with a Non-Depleted Embedded p-Island

Ultralow Specific On-Resistance High-Voltage SOI Lateral MOSFET

A RESURF-Enhanced P-Channel Trench SOI LDMOS with Ultralow Specific On-Resistance

Ultra-low Specific On-Resistance SOI Double-Gate Trench-Type MOSFET

New Power MOSFET with Beyond-1D-Limit RSP-BV Trade-Off and Superior Reverse Recovery Characteristics.

Ultralow Specific On-Resistance Trench MOSFET with a U-Shaped Extended Gate

An Ultralow Specific On-Resistance 200V LDMOS for Voltage Extension of a 0.18µm BCD Process

Dual-Gate Lateral Double-Diffused Metal-Oxide Semiconductor with Ultra-Low Specific On-Resistance

Ultralow specific on-resistance trench lateral power MOSFETs

Low On-Resistance LDMOS with Stepped Field Plates from 12V to 40V in 300-MM 90-NM BCD Technology

A Novel Planar Vertical Double-Diffused Metal-Oxide-semiconductor Field-Effect Transistor with Inhomogeneous Floating Islands

Optimized the breakdown voltage and specific on-resistance of double RESURF TMOS

Novel SOI Double-Gate MOSFET with a P-type Buried Layer

New Trench gate LDMOS for low power applications

A Low On-Resistance SOI LDMOS Using a Trench Gate and a Recessed Drain