Numerical Study on the Mechanism of Water and Gas Phase Transition and Water Redistribution after Purging Based on Two-Dimensional Multi-Phase Model

Lei Shi,Pengcheng Liu,Minggang Zheng,Sichuan Xu

DOI: https://doi.org/10.1016/j.enconman.2023.116725

IF: 10.4

2023-01-01

Energy Conversion and Management

Abstract:In this paper, a two-dimensional multi-phase proton exchange membrane fuel cell model was established to study the change regulation of water content, water vapor pressure, water saturation in the purge process under the humidity condition of purge gas, and the redistribution regulation of water after the shutdown purge. The nu-merical model was analyzed using COMSOL Multiphysics 6.0 software and verified by comparing the experi-mental results with the simulation results. The study results show that the humidity reduction of purge gas could improve the efficiency of the purge and effectively reduce the content of ionomer hydration water at the end of the purge. The water vapor pressure, in the end, is lower than the saturation vapor pressure at the purge gas humidity of 0%, 10%, and 20%, effectively suppressing the reproduction of liquid water after the purge. During the purge process, the minimum saturation (0.01) interface and the water-vapor phase change interface appear when the purge gas humidity is reduced to 20%. Furthermore, as the humidity of the purge gas decreases, these interfaces appear earlier and remain shorter, which is more effective for removing liquid water. After the purge, with the increase in purge gas humidity, the water redistribution phenomenon is gradually apparent, resulting in the content of the ionomer hydration water increasing again. This study provides a theoretical basis for studying water and gas transmission, phase transition, and water redistribution of the shutdown purge.