Abstract:Instantaneous frequency (IF) of shaft rotation is pivotal for bearing fault diagnosis under variable speed operations. However, shaft IF cannot always be measured as tachometers are not allowed to be installed in every case due to design reasons and cost concerns. Extracting the shaft IF ridge from time frequency representation (TFR) of vibration signals, therefore, becomes an alternative. Linear transform (LT), such as short time Fourier transform (STFT), has been widely adopted for such a purpose. Nevertheless, the accuracy of extracted IF ridges relies on the readability of TFR. Unfortunately, readability of TFR from STFT is often impaired by the smearing effect caused by non-synchronous frequencies between bases and signal components and limited time frequency resolution capability, which in turn adversely influences the accuracy of IF ridge extraction. To accurately extract IF ridges from vibration signals, this paper focuses on the first factor, which causes the smearing problem, and proposes a method named frequency matching linear transform (FMLT) to enhance the TFR, where transforming bases with frequencies varying with the shaft IF are constructed to alleviate the smearing effects. To construct the transforming bases with frequencies synchronous with shaft IF, a fast path optimization (FPO) algorithm, which generates all possible optimization paths among amplitude peaks and thereby ensures the continuity of extracted IF ridges, is adopted for IF pre-estimation. The TFR with improved readability can be subsequently obtained via FMLT, paving the way for accurate IF ridge extraction. Then, multiple IF ridges can be iteratively extracted using the FPO algorithm. The accuracy of extracted IF ridges before and after TFR enhancement is compared, indicating that the proposed FMLT can enhance the readability of TFR and lead to more accurate IF ridge extraction for bearing condition monitoring.

An Instantaneous Frequency Optimization Strategy for Bearing Fault Diagnosis under Varying Speed Conditions

Bearing Fault Diagnosis under Non-Stationary Conditions Based on a Speed Signal Resonance Component Demodulation Algorithm

Bearing Condition Monitoring Via Multiple Instantaneous Frequency Path Extraction from Enhanced Time Frequency Representation

Instantaneous Frequency Synchronized Generalized Stepwise Demodulation Transform for Bearing Fault Diagnosis

Bearing fault diagnosis under variable speed conditions on Adaptive time frequency extraction mode decomposition

Sparse and Low-Rank Decomposition of the Time–frequency Representation for Bearing Fault Diagnosis under Variable Speed Conditions

Fault Diagnosis of Bearing under Varying Speed Using Hilbert Computed Order Spectrum and Ensemble of Auto-Encoders

An improved tracking method of bearing characteristic frequencies in the time-frequency representation of vibration signal

An Adaptive and Tacholess Order Analysis Method Based on Enhanced Empirical Wavelet Transform for Fault Detection of Bearings with Varying Speeds

Adaptive tacholess order tracking method based on generalized linear chirplet transform and its application for bearing fault diagnosis

Time Frequency Representation Enhancement via Frequency Matching Linear Transform for Bearing Condition Monitoring under Variable Speeds

A time-varying instantaneous frequency fault features extraction method of rolling bearing under variable speed

Bearing failure diagnosis at time-varying speed based on adaptive clustered fractional Gabor transform

High-accuracy Fault Feature Extraction for Rolling Bearings under Time-Varying Speed Conditions Using an Iterative Envelope-Tracking Filter

Fault Diagnosis for Rolling Bearings under Unknown Time-Varying Speed Conditions with Sparse Representation

A Tacho-Free Technique for Bearing Fault Diagnosis Via the Oscillatory Behaviors Based Signal Decomposition and Generalized Demodulation

Adaptive Cost Function Ridge Estimation for Rolling Bearing Fault Diagnosis Under Variable Speed Conditions

Bearing Fault Diagnosis under Time-Varying Rotational Speed Via the Fault Characteristic Order (FCO) Index Based Demodulation and the Stepwise Resampling in the Fault Phase Angle (FPA) Domain

Rolling Bearing Fault Diagnosis under Time-Varying Speeds Based on Time-Characteristic Order Spectrum and Multi-Scale Domain Adaptation Network

Fault Diagnosis of Motor Bearings with Multiple Time-Frequency Extraction Method under Variable Speed Conditions

Bearing Fault Diagnosis Based on Energy Spectrum Statistics and Modified Mayfly Optimization Algorithm