Abstract:The introduction of food wastes into anaerobic digestion (AD) brings a promising scenario of increasing feedstock availability and overall energy production from AD. This study evaluated the biodegradability and methane potential from co-digestion of two typical food wastes, kitchen waste and chicken fat, with dairy manure. For single substrate, the bio-methane potential assays showed that kitchen waste had the highest methane yield of 352 L-CH4 kg(-1)-VS added, 92% more than dairy manure alone. Chicken fat at the same Volatile Solid (VS) level (2g L-1) inhibited bio-methane production. Addition of kitchen waste and chicken fat to a VS percentage of up to 40% improved overall methane yield by 44% and 34%, respectively. Synergistic effect was observed when either combining two or three substrates as AD feedstock, possibly as a result of increased biodegradability of organic materials in chicken fat and kitchen waste compared with dairy manure. Addition of chicken fat improved methane yield more than kitchen waste. However, addition of chicken fat VS over 0.8g L-1 should be cautiously done because it may cause reactor failure due to decrease in pH. The maximum methane yield was 425 L-CH4 kg(-1)-VS, achieved at a VS ratio of 2:2:1 for kitchen waste, chicken fat, and dairy manure. Results from batch AD experiment demonstrated that supplementing dairy manure to chicken fat and/or kitchen waste improved alkalinity of substrate due to the inclusion of more titratable bases in dairy manure, and therefore stabilized the methanogenesis and substantially improved biogas yield. A mixture of substrates of kitchen waste, chicken fat, and dairy manure at a ratio of 1:1:3 was fed to a continuously stirred tank reactor operated at organic loading rates of 3.28, 6.55, and 2.18g-COD L-1-day (hydraulic retention time of 20, 10, and 30days, respectively) under mesophilic condition, and methane production rate reached 0.65, 0.95, and 0.34 L-CH4 L-1-reactor-day.

Anaerobic Codigestion of Excess Sludge with Chicken Manure with a Focus on Methane Yield and Digestate Dewaterability

Comparison of High-Solids to Liquid Anaerobic Co-Digestion of Food Waste and Green Waste

Comparison of Anaerobic Co-Digestion of Buffalo Manure and Excess Sludge with Different Mixing Ratios under Thermophilic and Mesophilic Conditions

Methane Production by Anaerobic Co-digestion of Chicken Manure and Spartina Alterniflora Residue after Producing Methane

Improving methane productivity of waste activated sludge by ultrasound and alkali pretreatment in microbial electrolysis cell and anaerobic digestion coupled system

Biogas Production from Undiluted Chicken Manure and Maize Silage: A Study of Ammonia Inhibition in High Solids Anaerobic Digestion

Biohydrogen and Methane Production by Co-Digestion of Cassava Stillage and Excess Sludge under Thermophilic Condition.

Revealing the correlation of biomethane generation, DOM fluorescence, and microbial community in the mesophilic co-digestion of chicken manure and sheep manure at different mixture ratio

Anaerobic Co-digestion of Chicken Manure and Corn Straw: Gas Production, Biogas Fertilizer Effectiveness, and Microbial Diversity

Methane Production Dynamics of Co-Digestion of Cow Manure and Food Waste Under Mesophilic Condition

Vermicompost As an Accelerator of Methane Production

Biomethane production and microbial community change during the co-digestion of food waste and municipal sludge with different mix ratios

Improvement of anaerobic co-digestion of plant waste and excess sludge using calcium peroxide

Optimization of the Process Conditions for Methane Yield from Co-Digestion of Mixed Vegetable Residues and Pig Manure Using Response Surface Methodology

Calcium oxide enhances the anaerobic co-digestion of excess sludge and plant waste: performance and mechanism

Anaerobic co-digestion of linen, sugar beet pulp, and wheat straw with cow manure: effects of mixing ratio and transient change of co-substrate

Evaluation of anaerobic co-digestion of dairy manure with food wastes via bio-methane potential assay and CSTR reactor.

Anaerobic co-digestion of cabbage waste and cattle manure: Effect of mixing ratio and hydraulic retention time

Links between carbon/nitrogen ratio, synergy and microbial characteristics of long-term semi-continuous anaerobic co-digestion of food waste, cattle manure and corn straw

Enhanced methane production from the co-digestion of food waste and thermally hydrolyzed sludge filtrate

High value-added chemical production through anaerobic codigestion of corn straw with a microbial consortium, cow manure and cow digestion solution