Abstract:Catalytic upgrading of fast pyrolysis bio-oil from two different types of lignocellulosic biomass was conducted using an H-ZSM-5 catalyst at different temperatures. A fixed-bed pyrolysis reactor has been used to perform in situ catalytic pyrolysis experiments at temperatures of 673, 773, and 873 K, where the catalyst (H-ZSM-5) has been mixed with wood chips or lignin, and the pyrolysis and upgrading processes have been performed simultaneously. The fractionation method has been employed to determine the chemical composition of bio-oil samples after catalytic pyrolysis experiments by gas chromatography with mass spectroscopy (GCMS). Other characterization techniques, e.g., water content, viscosity, elemental analysis, pH, and bomb calorimetry have been used, and the obtained results have been compared with the non-catalytic pyrolysis method. The highest bio-oil yield has been reported for bio-oil obtained from softwood at 873 K for both non-catalytic and catalytic bio-oil samples. The results indicate that the main effect of H-ZSM-5 has been observed on the amount of water and oxygen for all bio-oil samples at three different temperatures, where a significant reduction has been achieved compared to non-catalytic bio-oil samples. In addition, a significant viscosity reduction has been reported compared to non-catalytic bio-oil samples, and less viscous bio-oil samples have been produced by catalytic pyrolysis. Furthermore, the obtained results show that the heating values have been increased for upgraded bio-oil samples compared to non-catalytic bio-oil samples. The GCMS analysis of the catalytic bio-oil samples (H-ZSM-5) indicates that toluene and methanol have shown very similar behavior in extracting bio-oil samples in contrast to non-catalytic experiments. However, methanol performed better for extracting chemicals at a higher temperature.

Valorization of Water Hyacinth Biomass for Bio-Oil Production Using A Novel Combinatorial Approach of Uv/H2o2 Advanced Oxidation Process Pretreatment and Catalytic Fast Pyrolysis over Zsm-5

Upgrading Phenolic Compounds and Bio-Oil Through Hydrodeoxygenation Using Highly Dispersed Pt/TiO2 Catalyst

Optimizing invasive plant biomass valorization: Deep eutectic solvents pre-treatment coupled with ZSM-5 catalyzed fast pyrolysis for superior bio-oil quality

Bio-oil Production from Sequential Two-Step Microwave-Assisted Catalytic Fast Pyrolysis of Water Hyacinth Using Ce-doped Γ-Al2o3/zro2 Composite Mesoporous Catalyst

In-depth Study of Synergism Between Torrefaction and Catalyst for Balanced Production of Bio-Oil from Rice Husk Pyrolysis Based on Hydrocarbons Production, Energy Yield and Deoxygenation Degree

Enhancing Production of Hydrocarbon-Rich Bio-Oil from Biomass Via Catalytic Fast Pyrolysis Coupled with Advanced Oxidation Process Pretreatment.

Synergistic enhancement of bio-oil quality through hydrochloric or acetic acid-washing pretreatment and catalytic fast pyrolysis of biomass

Valorization of Corn Straw for Liquid Hydrocarbon Production Via Catalytic Pyrolysis Coupled with Phanerochaete Chrysosporium Pretreatment

An approach for upgrading biomass and pyrolysis product quality using a combination of aqueous phase bio-oil washing and torrefaction pretreatment

Microwave-assisted catalytic upgrading of co-pyrolysis vapor using HZSM-5 and MCM-41 for bio-oil production: Co-feeding of soapstock and straw in a downdraft reactor

Effects of Hydrolysis and Oxidative Hydrolysis Pretreatments on Upgrading of the Water-Soluble Fraction of Bio-Oil Via Decarboxylation

Ex-situ Catalytic Upgrading of Vapors from Fast Microwave-Assisted Co-Pyrolysis of Chromolaena Odorata and Soybean Soapstock.

Microwave-assisted Catalytic Fast Pyrolysis Coupled with Microwave-Absorbent of Soapstock for Bio-Oil in a Downdraft Reactor

Synergetic deoxygenation and demineralization of biomass by wet torrefaction pretreatment and its influence on the compound distribution of bio-oil during catalytic pyrolysis

Hydrocarbon-Rich Bio-Oil Production from Ex Situ Catalytic Microwave Co-Pyrolysis of Peanut Shells and Low-Density Polyethylene over Zn-Modified Hierarchical Zeolite

Preparation of bio-oil enriched with phenolic compounds by combining acid-washing pretreatment and condensation technology

Alkane from Hydrodeoxygenation (HDO) Combined with In-Situ Multistage Condensation of Biomass Continuous Pyrolysis Bio-Oil Via Mixed Supports Catalyst Ni/HZSM-5-γ-Al2O3

Catalytic Hydrodeoxygenation of Fast Pyrolysis Bio-Oil from Saccharina japonica Alga for Bio-Oil Upgrading

Effect of aqueous phase bio-oil and its typical organic matter washing pretreatment on catalytic pyrolysis characteristics of biomass

Comparative Production of Bio-Oil from In Situ Catalytic Upgrading of Fast Pyrolysis of Lignocellulosic Biomass

Experimental Research on Selective Hydrogenation-Catalytic Pyrolysis of Water-Soluble Bio-Oil to Produce Olefins and Aromatics