Hydrothermal Recovery and Reuse of Oxidated By-Products in Magnesium Flue Gas Desulfurization: Experimental Studies and Molecular Dynamics Simulation

Yuzhe Liu,Peiyang Shi,Maofa Jiang

DOI: https://doi.org/10.1016/j.jece.2022.108099

IF: 7.7

2022-01-01

Journal of Environmental Chemical Engineering

Abstract:A large volume of highly concentrated magnesium salt solution is produced during magnesium flue gas desulfurization. Existing method of concentration recovery is relatively inefficient and uneconomical. To address this problem, a hydrothermal crystallization method was proposed to recover the by-products after oxidation. It was found that 80% of the salt solute was recovered in the form of MgSO4 center dot H2O under the following conditions: an initial magnesium concentration of 6.7%, temperature of 180 degrees C, and holding time of 90 min. The apparent activation energy during crystallization was 186.7 kJ mol(-1), indicating that the rate was controlled by a chemical reaction. In terms of microscopic properties, fewer water molecules within the clusters and stronger associations were crucial for the recovery of kieserite instead of epsomite. The nucleation of the magnesium sulfate salt may be attributed to the hydration inhibition in solvent-separated ion pairs and the transformation to contact-associated ion pairs. More importantly, the recovered products could be reused when calcined at 1150 degrees C for 60 min. Their chemical reactivity was satisfactory. High salt rejection, good water saving, and lower energy consumption are expected study results.