Abstract:The recycled powder produced in the process of crushing concrete and brick waste (C&BW) into recycled aggregate will cause environmental pollution. To realize the green full recycling of concrete and brick waste, the cement stabilization of crushed aggregate (CSCA) containing recycled brick-concrete composite micropowder (RBCP) and recycled brick-concrete composite aggregate (RBCA) is proposed. In this paper, RBCP, recycled brick-concrete composite fine aggregate (RBCFA), and recycled brick-concrete composite coarse aggregate (RBCCA) were the recycled materials from C&BW. The orthogonal test table was used to analyze the effects of the three recycled materials on the compaction characteristics, mechanical properties, and shrinkage behavior of CSCA at different dosages. The effects of RBCP, RBCCA, and RBCFA on the properties of CSCA are studied by variance analysis methods. On this basis, the micromorphology and the interface transition zone (ITZ) were studied for CSCA and the cement stabilization of crushed aggregate with RBCP, RBCFA, and RBCCA through scanning electron microscopy with energy dispersive spectroscopy (SEM/EDS), and the mechanism was revealed. The results indicate that the addition of RBCP and RBCA can increase the optimal water content while decreasing the optimal dry density of CSCA, and the influence of RBCCA on the optimal water content is greater than that of RBCFA. Three optimal composite replacement systems for CSCA, including 20% RBCP/20%RBCFA/40%RBCCA, are proposed and have the best mechanical and antishrinkage performance through the range analysis. Furthermore, the variance analysis test results show that RBCCA and RBCFA have the most significant effect on the compressive strength and shrinkage strain properties, while RBCP has the most significant effect on the bending tensile strength. It is found that RBCP played a filling effect and pozzolanic activity in the strength formation of CSCA. The SEM/EDS test shows that the CSCA with recycled materials produced the Ca/Si ratio in the interfacial zone between the cement paste and aggregate lower than the CSCA without recycled materials, the largest decline 52.83%. The research results of this paper can provide the potential application of RBCP and RBCA.

Mechanical Properties, Drying Shrinkage, and Nano-Scale Characteristics of Concrete Prepared with Zeolite Powder Pre-Coated Recycled Aggregate

Influence of Construction Conditions on Properties of Recycled Concrete

Strength, Chloride Ion Penetration, and Nanoscale Characteristics of Concrete Prepared with Nano-Silica Slurry Pre-Coated Recycled Aggregate

Effect Of Pozzolan Slurries On Recycled Aggregate Concrete: Mechanical And Durability Performance

Unlocking the Role of Recycled Aggregates in the Performance Enhancement and CO2 Capture of Reactive Magnesia Cement Formulations

Roles of enhanced ITZ in improving the mechanical properties of concrete prepared with different types of recycled aggregates

An Approach to Effectively Improve the Properties of Recycled Concrete Aggregate and Recycled Brick Aggregate by Micro-Nano Particle Reconstruction

Use of Nano-Silica as a Supplementary Cementitious Material in Recycled Aggregate Concrete: Hydration Characteristics, Mechanical Properties and Microstructure Assessment

Mechanical Properties and ITZ Microstructure of Recycled Aggregate Concrete Using Carbonated Recycled Coarse Aggregate

Sustainable Cement Mortar with Recycled Plastics Enabled by the Matrix-Aggregate Compatibility Improvement

Properties of Recycled Concrete Aggregates Strengthened by Different Types of Pozzolan Slurry

Study on the Effect of Recycled Coarse Aggregate on the Shrinkage Performance of Green Recycled Concrete

Study on mechanical performance and mesoscopic simulation of nano-SiO2 modified recycled aggregate concrete

Freeze–Thaw Cycle Durability and Mechanism Analysis of Zeolite Powder-Modified Recycled Concrete

Investigating the Effects of Recycled Micropowder and Aggregate on the Properties of Cement Stabilization of Crushed Aggregate (CSCA)

Compressive Behaviour and Microstructures of Concrete Incorporating Pretreated Recycled Powder/aggregates: the Coupling Effects of Calcination and Carbonization

Mechanical properties of recycled concrete with demolished waste concrete aggregate and clay brick aggregate

Study on Mechanical and Shrinkage Properties of High Belite Sulphoaluminate Cement-Based Green Recycled Aggregate Concrete

Effect of nano-SiO2 modified recycled coarse aggregate on the mechanical properties of recycled concrete

The Mechanical Properties and Microstructure of Tailing Recycled Aggregate Concrete