Abstract:Nowadays, consumer trends towards healthier and low fat products have a significant impact on the deep fat frying industry. The objective of this study was to design a modified deep fat fryer (MDF) to have a smaller surface area relative to height, with made a steam blanketing over the fryer. Different levels of water injection flow rates have been used (0.1, 0.2 and 0.3 ml/20 min. per 1 liter of tested oil), compared with conventional fryers (CDF). Frying was conducted at 170 ± 10 °C into sunflower oil using CDF (H√A = 0.24) and MDF (H√A = 0.8) in batch 8 min. 16 batches every day (eight hrs. /day)for up to 40 hrs (Consecutive five days). The modification was intended to related oil deterioration. Water injection had a dual effect. In comparison with CDF, water injection increased the acidity (expressed as oleic acid) from 0.34 % to 0.97 %, after 40 hrs at 170 ± 10 °C of deep fat frying, and a contrarily, the protective role was observed in all the other quality indices. Significant reductions in TBA values (from 8.9 to 4.81mg malonaldehyde/liter of tested oil), P-anisidine values (from 35.6 to 12.9), TPC contents (from 34.5% to 18.64%), conjugated diene (232 nm) (from 8 to 5.59) and conjugated triene (268 nm) (from 1.9 to 1.33) were recorded in sunflower oil compared with CDF. These quality indices of sunflower oil developed dramatically in the first level of water injection flow rate. Consequently, the first level of water injection had the highest (P≥0.05) inhibitory effect compared with the other levels of water injection. Fatty acid composition of fried oil properties during deep frying CDF and MDF designs were determined. There were significant differences (P≥0.05) of fatty acids composition between the fried oil induces during using of CDF and MDF designs. Total unsaturated fatty acid at MDF design gave the highest values. Also, organoleptic evaluation of fried potato chips by CDF and MDF were evaluated by panelists. Fried potato chips during the first level of water injection flow rate had the highest (P≥0.05) flavor (4), crisp (4.5), greasiness (4.6), and overall acceptability (4.8), compared with fried potato chips during other levels of water injection flow rates and with CDF. Findings suggest that determination of the oil quality indices are good makers of sensory evaluation during deep fat frying. Results indicated the changes in moisture content, oil uptake and shrinkage percentages of potato chips at different levels of water injection compared the control samples. The negative correlation coefficient between oil uptake and moisture content was high (r = -0.915) and linear regression equation for prediction the oil uptake y = 34.1064 – 2.0291X. Also, results suggest that during deep fat frying by MDF design may reduce the thermal deterioration of sunflower oil. Water injection can be applied as a simple method to improve oil quality during deep fat frying.

Dynamic Changes of 3-MCPD Esters and Glycidyl Esters Contents As Well As Oil Quality During Repeated Deep-Frying

Analysis of oxidation products and toxic compounds in edible and blended oil during the deep-frying of french fries

The Effect of Type of Oil and Degree of Degradation on Glycidyl Esters Content During the Frying of French Fries

Monitoring of heat-induced carcinogenic compounds (3-monochloropropane-1,2-diol esters and glycidyl esters) in fries

The occurrence of 3-monochloropropane-1,2-diol esters and glycidyl esters in vegetable oils during frying

Effects of Food Types, Frying Frequency, and Frying Temperature on 3-Monochloropropane-1,2-diol Esters and Glycidyl Esters Content in Palm Oil during Frying

The effects of chloride and the antioxidant capacity of fried foods on 3-chloro-1,2-propanediol esters and glycidyl esters during long-term deep-frying

Dynamic changes of fatty acids and related physical & chemical parameters during deep frying in fish oil supplemented blend oil

Comparative analysis of aroma compounds in French fries and palm oil at three crucial stages by GC/MS-olfactometry, odor activity values, and aroma recombination

Analysis of 8-oxooctanoate, 9-oxononanoate, fatty acids, oxidative stability, and iodine value during deep-frying of French fries in edible oils blended with palm oil

Quality investigation of the most consumed refined seed oils after French fries’ domestic short-term deep-frying process

Evaluation of polar compound distribution in edible oils under restaurant deep frying

Changes in stability, phytonutrients, 3-chloropropanol esters and glycidyl esters of peanut oil-based diacylglycerols during heat treatment

Lipid Quality Changes in French Fries, Chicken Croquettes, and Chicken Nuggets Fried with High-Linoleic and High-Oleic Sunflower Oils in Domestic Deep Fryers

Monitoring the Changes in Heat Transfer and Water Evaporation of French Fries during Frying to Analyze Its Oil Uptake and Quality

Impact of deep-fat frying cycles on the physicochemical characteristics of two edible vegetable oils marketed in Algeria

Influence of steam singlet method on oil quality during deep fat frying on a modified fryer

Improvement in thermal stability of soybean oil by blending with camellia oil during deep fat frying

Evaluation of Chemical and Nutritional Changes in Chips, Chicken Nuggets, and Broccoli after Deep-Frying with Extra Virgin Olive Oil, Canola, and Grapeseed Oils

EFFECT OF REPEATED DEEP-FAT FRYING OF FRENCH FRIES IN SUNFLOWER AND PALM OILS ON THE ACRYLAMIDE CONTENT

Introducing degummed water‐extracted wild almond oil as a safe vegetable oil through the quality evaluation of par‐fried potato sticks and oil thermo‐oxidative stability during a continuous prolonged deep‐fat frying process