Multifunctional Ca9NaZn1-Mg (PO4)7:Eu2+ phosphor for full-spectrum lighting, optical thermometry and pressure sensor applications

Dan Zhang,Baofeng Zheng,Zhibo Zheng,Liping Li,Qing Yang,Yanhua Song,Bo Zou,Haifeng Zou

DOI: https://doi.org/10.1016/j.cej.2021.133805

IF: 15.1

2021-01-01

Chemical Engineering Journal

Abstract:• Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ phosphors realizes full spectrum white light emission. • Warm white light emitting phosphor is realized by the Mg 2+ induction effect. • Under pressure, up to ∼16.48 GPa, phosphors exhibit a high pressure sensitivity. • The maximum relative sensitivity (S r ) is found to be 0.81% K −1 at 398 K. • The warm WLED device exhibits high R a , low CCT and excellent color stability. The Eu 2+ ions in Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ phosohor occupying the Ca3, Ca1/Ca2, and Na sites bring about a bright yellow light with peaks at about 415, 490, and 570 nm, respectively. The induction effect of Mg 2+ ions on Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ gradually decreases the occupation of Eu 2+ in Ca3 site (415 nm), reducing the harm of blue light to human health. Meanwhile, the emission of Eu 2+ ions at Na sites emerge a great red shift from 562 to 634 nm due to the change of local environment caused by Mg 2+ ions, and the emission color is gradually adjusted from yellow to warm white with increasing the red light component. The color rendering index (CRI) of WLED devices prepared by combination of Ca 9 NaZn 1- y Mg y (PO 4 ) 7 :1.0%Eu 2+ ( y = 0 and 0.6) phosphors with 375 nm chip promotes from 79.9 to 90.3. Good optical properties of these LED devices confirm the potential of the Ca 9 NaZn 1- y Mg y (PO 4 ) 7 :1.0%Eu 2+ phosphors in full-visible-spectrum lighting. In addition, the optical thermometric properties of Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ phosphors were analyzed in the temperature range of 298–498 K. The maximum relative sensitivity S r is found to be 0.81% K −1 at 398 K, indicating the potential applications of the Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ phosphors in optical thermometry. The pressure-dependent luminescence properties of Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ , that is, the red shift of the band centroids and the changes of the band ratios, make the Ca 9 NaZn(PO 4 ) 7 :1.0%Eu 2+ phosphor suitable for optical pressure sensing (the calculated shift rate dλ/dP ≈ 5.21 nm/GPa).