Abstract:A compound droplet subject to three-dimensional oscillatory shear flow is studied using a three-phase lattice Boltzmann model. Firstly, focusing on low values of capillary number (Ca) where the compound droplet eventually reaches steady-state oscillatory condition, we study the effect of oscillatory period, viscosities of inner and outer fluids of the compound droplet, wall confinement and Ca on the droplet behavior. As the oscillatory period increases, the maximum deformation parameters gradually approach the steady-state values in the corresponding simple shear flow for both inner and outer droplets, and the compound droplet is more synchronous with applied shear. We demonstrate for the first time that due to high pressure near two tips inside the outer droplet the inner droplet may rotate counterintuitively in a direction opposite to the outer one. The compound droplet undergoes larger deformation when either droplet is less viscous, which also decreases the synchronization between inner and outer droplets. Increasing confinement ratio not only promotes the deformations of both constituent droplets, but also makes them more synchronous with applied shear. It is also found that the maximum deformation parameters of both droplets increase linearly with Ca up to <math>Ca=0.35</math> but deviate from the linearity at higher Ca, where multipeaked oscillations are observed for the deformation of the inner droplet, which can be due to the extensional flow resulting from the rapid contraction of the outer droplet. We then analyze the breakup behavior of compound droplet in the oscillatory shear flow for varying confinement ratios, and compare the findings with those in simple shear flow. The critical capillary number for droplet breakup exhibits a non-monotonic behavior with the confinement ratio in both shear flows, but its value is always higher in oscillatory shear flow than in simple shear flow. As the confinement ratio increases, in the case of oscillatory shear flow, the droplet undergoes a transition from inner ternary breakup to inner binary breakup, distinct from the one observed in the case of simple shear flow. Finally, increasing oscillatory period is found to not only decrease the critical capillary number but also change the mode of droplet breakup.

Numerical Simulation on Free Oscillation Interfacial Dynamics of Single-Core Compound Droplet Driven by Shell Deformation

Effect of Inner Cylinder Configuration on Liquid Droplet Dispersion and Size Distributions in a Taylor-Couette Reactor

Numerical simulation of deformation and breakage of compound droplet in air flow

Numerical Simulation of Droplet Generation in Cross-Junction Microchannel under Changing Dispersion Phase Velocities

Deformation and breakup of a compound droplet in three-dimensional oscillatory shear flow

Numerical Study on Droplet Deformation in Periodic Pulsatile Shear Flow and Effects of Inertia

Role of surfactant-induced Marangoni effects in droplet dynamics on a solid surface in shear flow

Numerical investigation of micro-droplets mixing in electrowetting-on-dielectric digital microfluidics: The merging process and frequency response

Damped shape oscillations of a viscous compound droplet suspended in a viscous host fluid

Scurvy in an elephant.

Dynamic Formation and Scaling Law of Hollow Droplet with Gas/oil/water System in Dual‐coaxial Microfluidic Devices

Droplet Oscillation After Impact On A Solid Surface

Numerical simulation on partial coalescence of a droplet with different impact velocities

Behavior of Compound Materials on Superhydrophobic Cylinders: Effects of Droplet’s Size and Interface Angle

Collision Dynamics and Deformation Behaviors of Multi-Core Compound Droplet Pairs in Microchannel Flow

Numerical Simulation of Droplet Deformation in Convective Flows

Flow structure of compound droplets moving in microchannels

Simulation of dynamic characteristics of droplet impact on liquid film

Numerical Simulation of Liquid Droplet Coalescence and Breakup

Effect of interface deformation on hydrodynamics of liquid–liquid two-phase flow in a confined microchannel

The dynamic effects of surfactants on droplet formation in coaxial microfluidic devices