Abstract:The suspension system of an automobile is responsible for smoothing out the ride and maintaining control of the vehicle. However, traditional passive suspension system does not achieve satisfactory performance due to a lack of control over the damping force. Semi-active suspension (SAS) systems are now even more feasible because to their reduced power consumption, which is a result of the quick advancement of electronic sensors and actuator technologyOne of the greatest and most dependable semi-active control components available for suspension systems that can further enhance ride comfort is the magnetorheological (MR) damper, which produces a regulated damping force.This study focuses on developing a controller scheme named Fuzzy logic with Proportional-Integral-Derivative (Fuzzy-PID) and Fuzzy logic with Propor-tional-Integral-Derivative and Active Force Control (Fuzzy-PID-AFC) controllers to control the damping force of the MR damper to achieve better ride comfort by reducing vibration from the simulated road bump. A sinusoidal vibration source is applied to the quarter car test rig to investigate the improvement of ride comfort as well as to ascertain the new hybrid Fuzzy-PID-AFC controller robustness. The study found that a comparison of sprung mass acceleration signals from the passive suspension with Fuzzy-PID and Fuzzy-PID-AFC shows improvement to the sprung mass acceleration by 17.7 % and 32 %, respectively. As a result, the hybrid Fuzzy-PID-AFC controller outperforms the conventional Fuzzy-PID controller in the vehicle vibration control of the SAS system with MR damper. The control system may be further improved by implementing a hybridized iterative learning method to get a more accurate and dynamic estimation of mass for the Active Force Control controller.

An Adaptive Sliding Mode Fault-Tolerant Control for Semi-Active Suspensions with Magnetorheological Dampers Based on T-S Fuzzy Vehicle Models

Adaptive Sliding Mode Fault Tolerant Control for Semi-Active Suspension Using Magnetorheological Dampers

Functional Based Adaptive and Fuzzy Sliding Controller for Non-Autonomous Active Suspension System

Adaptive Sliding Controller with Self-Tuning Fuzzy Compensation for Vehicle Suspension Control

A New Model-Free Adaptive Sliding Controller for Active Suspension System.

On Fuzzy Control Strategy of Nonlinear Semi-Active Suspension System

Fault detection and fault tolerant control of vehicle semi-active suspension system with magnetorheological dampers

Model-free adaptive sliding controller for automotive active suspensions

Semi-active fuzzy cooperative control of vehicle suspension with a magnetorheological damper

An adaptive backstepping sliding mode control strategy for the magnetorheological semi-active suspension

Fault‐tolerant Sliding Mode Control for Uncertain Active Suspension Systems Against Simultaneous Actuator and Sensor Faults Via a Novel Sliding Mode Observer

Hybrid Fuzzy Control of Semi-Active Suspension System Using Magnetorheological Damper

Fuzzy Control for Uncertain Vehicle Active Suspension Systems Via Dynamic Sliding-Mode Approach.

Control and Simulation of Semi-Active Suspension Based on MRF Damper

A New Controller for the Semi-Active Suspension System with Magnetorheological Dampers

Adaptive Fuzzy Sliding Mode Control for Magneto-Rheological Suspension System Considering Nonlinearity and Time Delay

Higher Order Sliding Mode Control for Active Suspension Systems Subject to Actuator Faults and Disturbances

A Takagi-Sageno Fuzzy Model-Based Control Strategy for MR Semiactive Suspension with Asymmetric Actuator Saturation Constraint

A Sliding Mode Semi-Active Control of Suspension System Subject to Uncertainties

Sliding Mode Observation and Control for Semi-Active Suspension Based on Self-Sensing Magnetorheological Damper

Active Force Control for Semi-Active Suspension with Magnetorheological Damper