Abstract:This paper discussed the limitation of the laser-induced incandescence (LII) method for the measurement of soot in different laminar pulverized coal flames and explored the soot formation characteristic. Multiple methods, including digital photography, thermophoretic sampling, elastic laser scattering (ELS), and LII methods, were adopted to laboratory-scale laminar pulverized coal flames with different coal types (anthracite, lignite, and bituminous coal) and coal particle sizes (61-90, 90-100, and 100-154 mu m). The flame structure, the morphology of dominant particles in different combustion regions, and the spatial distribution of soot and micron-sized carbonaceous particles were obtained and analyzed. The optical measurement and sampling results showed that the soot yield was so low that the LII signal from soot did not dominate in the detection area for anthracite, lignite, and the larger size fraction bituminous coal flames. In particular, a comparison of LII and scattering signals indicated that the vast majority of the LII signal was excited from char and unburned coal for anthracite flame, and char combustion was predominant during the combustion process. Moreover, the coal particles were more dispersed for the larger particle size fraction bituminous coal flames, which favored soot oxidation but did not favor local fuel-rich combustion and the formation of soot. Therefore, in the present study, the soot yield was high enough only in 61-90 mu m bituminous coal flame, and the interference LII signal from char or unburned coal particles could be neglected by carefully controlling the laser fluence. It was also found that the LII signal intensity increased as the particle size of the pulverized coal jet decreased in the noncombustion case, which could be explained by the smaller total emission surface area with larger particle size. In addition, the temperature of heated coal particles was also lower as the coal particle size increased, which resulted in the weaker LII signal from coal particles. On the basis of this, a new phenomenon of primary fragmentation of coal particles in pulverized coal flames was observed for the first time by LII measurement, which could provide a potential method for the study of primary fragmentation for coal particles.

Experimental Studies on Soot in MILD Oxy-Coal Combustion Flame: Sampling, Microscopic Characteristics, Chemical Compositions and Formation Mechanism

Characteristics Of Submicron Particulate Matters Formed In The Early Stage Of Oxy-Fuel Coal Combustion

Effects of Na and Fe on the Formation of Coal-Derived Soot in a Two-Stage Flat-Flame Burner

Insight into soot formed in coal combustion flame: Evolution of physiochemical structure, oxidation reactivity

Ultrafine Particle Formation in Pulverized Coal, Biomass, and Waste Combustion: Understanding the Relationship with Flame Synthesis Process

Effect of CO2/H2O on the Incipient Ultrafine Particulate Matter Formation in Oxy-fuel Combustion of High-Sodium Lignite

Experimental analysis of the effect of oxygen concentration on soot formation in ethylene diffusion flame

Evolution of physicochemical characteristics of soot in a single coal combustion flame

Large Eddy Simulation of Soot Formation in a Turbulent Lifted Flame with a Discretized Population Balance and a Reduced Kinetic Mechanism

Soot Formation and Distribution in Coal Jet Flames over a Broad Range of Coal Concentration

Soot particles analysis in laminar premixed propane/oxygen (C3H8/O2) flames using published measurement data

Structure and Behavior of Soot in Pulverized-Coal Flame

Morphology and Fractal Dimension of Size-Resolved Soot Particles Emitted from Combustion Sources

Experimental and simulation studies on flame characteristics and soot formation of C2H2 jet flames

Experimental Study of Soot Formation in Coal Combustion Process

Role of Dimethyl Ether in Incipient Soot Formation in Premixed Ethylene Flames

Experimental Investigation on the Size-Dependent Maturity of Soot Particles in Laminar Premixed Ethylene Burner-Stabilized Stagnation Flames

Optical Investigations on Particles Evolution and Flame Properties During Pulverized Coal Combustion in O2/N2 and O2/CO2 Conditions

Evolution of structure and oxidation reactivity from early-stage soot to mature soot sampled from a laminar coflow diffusion flame of ethylene

Temperature and NOx Distribution Characteristics of Coal Particles under High-Temperature and Low-Oxygen Environments Simulating MILD Oxy-Coal Combustion Conditions

Influences of Coal Type and Particle Size on Soot Measurement by Laser-Induced Incandescence and Soot Formation Characteristics in Laminar Pulverized Coal Flames