Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Structure and Behavior of Soot in Pulverized-Coal Flame

Characteristics Of Submicron Particulate Matters Formed In The Early Stage Of Oxy-Fuel Coal Combustion

Effects of Na and Fe on the Formation of Coal-Derived Soot in a Two-Stage Flat-Flame Burner

Ultrafine Particle Formation in Pulverized Coal, Biomass, and Waste Combustion: Understanding the Relationship with Flame Synthesis Process

Ultrafine particulate matter formation in the early stage of pulverized coal combustion of high-sodium lignite

Insight into soot formed in coal combustion flame: Evolution of physiochemical structure, oxidation reactivity

Measurements and Modelling of Oxy-Fuel Coal Combustion

Experimental Study of Soot Formation in Coal Combustion Process

Flamelet LES of a Swirl-Stabilized Multi-Stream Pulverized Coal Burner in Air and Oxy-Fuel Atmospheres with Pollutant Formation

Flamelet LES of a Turbulent Pulverized Solid Fuel Flame Using a Detailed Phenomenological Soot Model

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Experimental Studies on Soot in MILD Oxy-Coal Combustion Flame: Sampling, Microscopic Characteristics, Chemical Compositions and Formation Mechanism

Optical Investigations on Particles Evolution and Flame Properties During Pulverized Coal Combustion in O2/N2 and O2/CO2 Conditions

Evolution of physicochemical characteristics of soot in a single coal combustion flame

Soot Formation and Distribution in Coal Jet Flames over a Broad Range of Coal Concentration

Large Eddy Simulation of Soot Formation in a Laboratory Pulverized Coal Flame

The electron microscopy study of ash deposition in the pulverized-coal burned

Effects of Fuel Structure on Structural Characteristics of Soot Aggregates

Study on the Effect of Coal Grain Size on the Morphology of Soot Generated During Combustion

Coal-Derived Soot Behaviors in O2/N2 and O2/CO2 Atmospheres, Studied Through a 1-D Transient Coal Combustion Model

Analysis Of Individual Pm1 From Pulverized-Coal Combustion