Abstract:The gasification behavior of coal under high-temperature and high-pressure conditions is important from the perspective of designing and optimizing high efficiency gasifiers and troubleshooting existing gasifiers. The effect of feed particle size, density, temperature, and pressure on char porous structure, morphology, reflectance, and reactivity under conditions relevant to entrained-flow gasification was investigated. The chars were generated over a range of temperatures (1100, 1300, and 1400 °C at 11.3 bar for the −150 + 106 μm fraction), pressures (3.4, 6.2, 11.3, 15.5, and 21.7 bar at 1300 °C for the −150 + 106 μm fraction), for various size fractions (−106 + 75, −150 + 106, −212 + 150, −420 + 212 μm at 1300 °C and 11.3 bar), and density fractions ( 1.6g/cc for the −106 + 75 μm at 1300 °C and 11.3 bar) of Pittsburgh No.8 bituminous coal using a high-pressure, high-temperature flow reactor (HPHTFR) in a equimolar mixture of CO2 and N2. Chars were characterized for conversion, morphology, thermal swelling ratio, and reactivity using ash tracer technique, oil immersion microscopy, tap density technique, and a thermogravimetric analyzer, respectively, and the results were statistically analyzed to determine for effects by feed particle density, feed particle size, temperature, and pressure. The results showed that the conversion was most affected by temperature, followed by feed particle size, pressure, and feed particle density. In the case of structural characteristics (i.e., thermal swelling ratio and group-I char concentration), feed particle density affected group-I concentration, while both feed particle size and feed particle density affected thermal swelling ratio. Variation in vitrinite content and fragmentation affected the thermal swelling ratio and group-I char concentration. In the case of intrinsic reactivity, particle density showed the largest effect, followed by temperature, particle size, and pressure. An increase in reflectance and temperature was found to inversely affect intrinsic reactivity.

Insights into the Effect of Particle Size on Coal Char Particle Gasification by Thermogravimetric Analyzer and High Temperature Stage Microscope

Study on the Variation of Coal Properties for Different Coal Diameters and Its Effects on Combustion Characteristics

Experimental Analysis of Intrinsic Kinetics and Rate Profiles for Coal Char Conversion under Different Atmospheres

Non-isothermal Thermogravimetric Investigation on Mutual Effect Between Bituminite and Anthracite in Blends for Blast Furnace Injection

Assessment of the Impact of Pyrolysis Conditions on Char Reactivity Through Orthogonal Experimental-Based Grey Relational Analysis

CFD Simulation of the Steam Gasification of Millimeter-Sized Char Particle Using Thermally Thick Treatment

Effect of Microstructures on Char Combustion Reactivity

Granularity Collocation of Single Coal on Comprehensive Combustion of Blends

Effects of Pyrolysis Atmosphere and Temperature on Coal Char Characteristics and Gasification Reactivity

Gas Emissions from Blends of Bituminous Coal and Biomass Chars under Different Pyrolysis Conditions

Effect of Specific Surface Area and Ash Content on the Mechanisms of Bituminous Coal Char Gasification

Structural and Gasification Kinetic Studies on Co-pyrolysis Chars of Coal and Biomass

A comparative study on the intrinsic reactivity and structural evolution during gasification of chars from biomass and different rank coals

Interaction between Coal and Biomass during Co-Gasification: A Perspective Based on the Separation of Blended Char

Microstructural And Reactivity Changes Of Coal Char During Steam Gasification At Low-Medium Temperature

Effect of Temperature, Pressure, Feed Particle Size, and Feed Particle Density on Structural Characteristics and Reactivity of Chars Generated during Gasification of Pittsburgh No.8 Coal in a High-Pressure, High-Temperature Flow Reactor

Gasification Kinetics of Bituminous Coal Char in the Mixture of CO2, H2O, CO, and H2

Influence of Reactant Atmospheres and Temperature on Mechanism of Gasification of Coal Char Derived from Lignite

Combustion Kinetic Analysis of Group A Coal from Huainan Mining Area based on TG Experiment

Investigation of Coal Char-Slag Transition at High Temperature

The intrinsic reactivity of coal char conversion compared under different conditions of O2/CO2, O2/H2O and air atmospheres