Abstract:Reducing the vibration responses caused by the unbalance of the rotor is a crucial technology to ensure the safe and efficient operation of high-speed rotating machinery. For the flexible rotor system, the unbalance responses of rotors vary in different radial directions due to the anisotropic stiffness. The holospectrum technique using multi-sensor fusion provides ideas to solve this issue. The standard balancing method based on the holospectrum technique takes the Initial Phase Vector (IPV) as the balancing object, which could not represent the unbalance of flexible rotors correctly. In addition, the operating speed of the flexible rotor is generally higher than the first critical speed (FCS), making it necessary to fulfill the balancing of the first two modal shapes respectively in two steps. The above-mentioned procedure is not only very dangerous but also requires a large number of test runs resulting in corresponding wastages. In order to solve the issues mentioned above, a synchronous holo-balancing method for flexible rotors based on the modified initial phase vector (MIPV) is developed in this paper. Firstly, to tackle the limitation of IPV, the concept of equivalent rotating frequency circle is presented and then the MIPV is proposed as a new balancing object. MIPV could linearly represent the unbalance of the flexible rotor and increase the accuracy of holo-balancing. Secondly, the synchronous holo-balancing method is carried out to achieve the balancing at the speed below the FCS, reducing the complexity and danger of test runs at high operating speeds. And the synchronous balancing procedures based on the MIPV are further summarized in detail. Finally, two experimental results with different operating speeds and probe installations validate the feasibility and effectiveness of the proposed method. Compared with other traditional balancing methods, the proposed method can minimize the residual vibration and achieve state-of-the-art performances.

Precession Trend Analysis and Balancing Strategy for Rotors with Multi-fault

Rigid Rotor Dynamic Balancing with the Influence Coefficient Method

Rigid Rotor Dynamic Balancing by Two-Plane Correction with the Influence Coefficient Method

Research on Vibration Response of a Multi-Faulted Rotor System Using LMD-based Time-Frequency Representation

Collaborative Simulation of Compound Dynamic Balancing Device for High-Speed Rotor System

Unbalance related rotor precession behavior analysis and modification to the holobalancing method

Unbalance Compensation by Recursive Seeking Unbalance Mass Position in Active Magnetic Bearing-Rotor System

A Study on the Improvement of Balancing Target Selection and Holographic Dynamic Balancing Method

A Balancing Method for Multi-Disc Flexible Rotors without Trial Weights

Rotor balancing based on holospectrum analysis: principle and practice

A New Transient Field Balancing Method of A Rotor System Based on Empirical Mode Decomposition

Unbalance Compensation for Active Magnetic Bearing Rotor System Using a Variable Step Size Real-Time Iterative Seeking Algorithm.

An Improved Holospectrum-Based Balancing Method for Rotor Systems with Anisotropic Stiffness

Transient Balancing of Rotor Based on Non-stationary Information

A Synchronous Holo-Balancing Method for Flexible Rotors Based on the Modified Initial Phase Vector

A New Dynamic Balance Framework Based on Blind Source Separation under Multiple Fault Conditions

A New Field Unbalance Estimation Method For Flexible Rotors

THE OPTIMIZATION TECHNIQUE-BASED BALANCING OF FLEXIBLE ROTORS WITHOUT TEST RUNS

Phase Compensation Method of Holobalancing

Dynamic balancing of super-critical rotating structures using slow-speed data via parametric excitation

Fault Analysis and Optimal Balancing of Bowing of Steam Turbine Rotor Under Long-Term Service