Advanced Treatment of Simulated Bio-Treated Piggery Wastewater by a Novel Electrolysis Process

Yalin Duan,Jianghui Du,Yuyan Cai,Zhiying Han

DOI: https://doi.org/10.13031/aim.201900733

2019-01-01

Abstract:Biological processes, such as sequencing batch reactor (SBR), Anoxic/Oixc (A/O), are widely used for piggery wastewater treatment. Due to failure of pH control in aerobic phase, and the competition between phosphorus accumulating organisms (PAOs) and denitrifiers on carbon source during anoxic phase, the concentrations of ammonia and phosphate in effluent from bio-treated piggery wastewater are usually high struvite (MgNH4PO4·6H2O) precipitation obtained by electrolysis equipped with magnesium anode, has been attracting more and more attention for its removing ammonia and phosphate efficiently. Meanwhile, the struvite produced during electrolysis can be used as a fertilizer. However, the rapid rise of pH in the electrolysis cell always leads to a failure of struvite formation. Moreover, the molar ratio of ammonia nitrogen to phosphate in effluent from bio-treated piggery wastewater is always greater than 1.0, which suggests the ammonia nitrogen needs to be remained in electrolyte. In this study, a novel electrolysis system was established, in which a sacrificial magnesium anode cell (Mg-cell) and a titanium anode cell (Ti-cell) were integrated together. The simulated bio-treated piggery wastewater went through Mg-cell and Ti-cell in sequence. The Mg-cell is ran to recover phosphorus and ammonia nitrogen as struvite till the pH increases to 9.0, while the followed Ti-cell is used to remove residual ammonia nitrogen and reduce the pH of electrolyte from Mg-cell with addition of NaCl. The results show that phosphate concentration in the effluent from Ti-cell combined with Mg-cell was lower than 6.0 mg/L, and the residual ammonia nitrogen was undetected with total electrolysis time of 2.5h（two running cycle）. The results of study will provide references for advanced treatment of effluent from bio-treated piggery wastewater by a novel electrolysis process.