Abstract:In this study, an exhaust system compliant with future regulations was developed for a non-road 110PS engine with a Tier-4f aftertreatment system, and the emission characteristics of the engine were investigated in the non-road transient mode (NRTC). For the system to comply with future exhaust regulations, a DPF was installed, and an electrical heated catalyst (EHC) device was installed to manage exhaust gas temperature. The emission characteristics of exhaust gas were examined according to the power and applied duration of EHC, and the effects of catalyst coating and the urea water solution (UWS) injection map on NOx reduction, NH3 slip, and N2O emissions in NRTC mode were investigated. The application of a 4 kW class EHC system enables the lowering of the injection starting temperature of the UWS, as reliable gas heating (heating duration control) is guaranteed. When the injection starting temperature (based on the SCR inlet temperature) was set to 150 °C, NSR map, (III) in conjunction with the operation of the EHC, effectively achieved significant NOx reduction in NRTC mode without deposit and wetting occurring in the mixer and exhaust pipe. Regarding changes in EHC power from 3 kW to 4 kW, it was observed that a NOx reduction of 0.05 g/kWh occurs in the cold NRTC mode, but in the hot NRTC mode, it was found that the relative decrease in the UWS is due to the increased NO2 conversion efficiency as a result of the oxidation catalyst, making 3 kW more advantageous. Furthermore, due to the increase in NO2 concentration caused by the oxidation catalyst and the increase in the low-temperature injected UWS, NH4NO3 was formed, which resulted in an increase in PM emissions and a significant increase in N2O emissions around an exhaust temperature of 250 °C. When the EHC power was set to 3 kW and the volume of oxidation catalyst and the amount of UWS injection were adjusted, applying EHC in the NRTC mode resulted in an additional NOx reduction of 58.6% and 88.4% in cold and hot modes, respectively, compared with not using EHC, with a fuel penalty of approximately 1.67%, while limiting the peak concentrations of N2O and NH3.

4709 Characteristics of Unregulated Harmful Emissions of Diesel Engine with Low Temperature Combustion

Gas Emissions and Particulate Matter of Non-Road Diesel Engine Fueled with F-T Diesel with EGR

Characterization of Gas and Particulate Phase Organic Emissions (C 9 -C 37 ) from a Diesel Engine and the Effect of Abatement Devices.

Oxygen uptake/supply dependency in human sepsis: does it increase the risk of multisystem organ failure?

Fuel Consumption and Emission Reduction for Non-Road Diesel Engines with Electrically Heated Catalysts

Control of Harmful Hydrocarbon Species in the Exhaust of Modern Advanced GDI Engines

Enhanced Diesel Emissions at Low Ambient Temperature: Hazardous Materials in Fine Particles.

Impact of engine control variables on low load combustion efficiency and exhaust emissions of a methane-diesel dual fuel engine

Effect of Post-Injection on Combustion and Exhaust Emissions in DI Diesel Engine

Combustion and emission characteristics of diesel with different distillation ranges on the China-VI diesel engine

Experimental Investigation of Unregulated Emissions Using Low-Percent Methanol-Gasoline Blend Fuels

Research on low temperature combustion of homogeneous charge induced ignition (HCII) in a light-duty diesel engine

The Influence of Alcohol Additives and EGR on the Combustion and Emission Characteristics of Diesel Engine under High-Load Condition

Formaldehyde, Acetaldehyde and Other Aldehyde Emissions from HCCI/SI Gasoline Engine Equipped with Prototype Catalyst

Particulate matter emission from a heavy duty diesel engine with three binary blends

Usefulness of urinary 6β-hydroxycortisol (6βOHF) excretion in the diagnosis of Cusing's syndrome

Unregulated Emissions and Combustion Characteristics of Low-Content Methanol−Gasoline Blended Fuels

Combustion Behaviors and Unregular Emission Characteristics in an Ammonia–Diesel Engine

Experimental Research on Alcohols, Aldehydes, Aromatic Hydrocarbons and Olefins Emissions from Alcohols Fuelled Vehicles

Investigation on Emission Characteristics of A Compression Ignition Engine with Oxygenated Fuels and Exhaust Gas Recirculation

Baby walkers —an underestimated hazard for our children?