Abstract:For the performance improvement of carbon dioxide heat pump systems, two new systems, a mechanical subcooling heat pump system that auxiliary cycle with ejector and a mechanical subcooling heat pump system that major cycle with ejector are proposed. The new systems combine the advantages of mechanical subcooling and ejectors. Three original carbon dioxide systems including a base system, a base system with ejector and a mechanical subcooling heat pump system are chosen as comparison systems to demonstrate the advantages of new systems. Meanwhile, three kinds of heating terminals and six typical cities in different regions are selected for comprehensive evaluation. Furthermore, the optimal operating conditions for each system with traditionally designed radiator, floor-coil radiator and small temperature difference fan-coil unit as terminals applied in different regions are obtained through multi-objective optimization. Compared with the base system, the coefficient of performance of the new system that auxiliary cycle with ejector and the new system that major cycle with ejector are improved by 17.58–20.90 % and 25.78–26.87 %, respectively, under rated working conditions. More importantly, the above new modified systems can operate at optimal conditions due to the reduction of optimal major discharge pressure. The new system that major cycle with ejector also reduces the minimum evaporating temperature limit to −40 °C, providing better low-temperature adaptability. Compared with the original mechanical subcooling system, the initial investment cost of the new system that major cycle with ejector is increased by only about 1.46–3.41 % under the optimal design conditions. For cities other than Harbin, the life cycle cost of the base system with ejector is lower than that of all remaining systems throughout the entire life cycle, which is the preferred system. In addition, the new system that major cycle with ejector is also a system that could be considered for selection. The life cycle cost of the new system that major cycle with ejector can be below that of the original mechanical subcooling system within 7 years and that's an acceptable amount of time. For Harbin, the life cycle cost of the new system that major cycle with ejector is lower than that of the base system with ejector after 6 years of running time. And the life cycle cost of the new system that major cycle with ejector is 12.7 % lower than that of the base system with ejector when the operating time reaches 15 years. The new system that major cycle with ejector will be more competitive in modifying the carbon dioxide heat pump systems if the equipment quality can be improved to extend operating time. The above analysis will provide a reference for the selection of systems and operating schemes in different regions.

Rational Assessment and Selection of Air Source Heat Pump System Operating with CO2 and R407C for Electric Bus

Experimental Study on Heating Performance of a CO2 Heat Pump System for an Electric Bus

Experimental Thermodynamic Investigation on the Refrigerant Charge in a Transcritical CO2 Electric Bus Air Conditioning System

Experimental Investigations on the Performance of a Single-Stage Compound Air-Source Heat Pump Using CO2/R600a in Cold Regions

A Comprehensive Assessment of the Refrigerant Charging Amount on the Global Performance of a Transcritical CO2-Based Bus Air Conditioning and Heat Pump System

Experimental and Theoretical Assessments on the Systematic Performance of a Single-Stage Air-Source Heat Pump Using Ternary Mixture in Cold Regions

Performance Investigation on a Novel Air-Source Heat Pump Using CO2/HC for Recirculated Water Heater in Cold Regions

Energy and Exergy Analyses of a Transcritical CO2 Air Conditioning System for an Electric Bus

Global Selection Appraisal Study for Heat Pump System of Electric Vehicle Based on Energetic, Economic, and Environmental Analysis

Energetic, Economic, Environmental Investigation of Carbon Dioxide As the Refrigeration Alternative in New Energy Bus/railway Vehicles' Air Conditioning Systems

SIMULATION AND COMPARISON OF AIR-SOURCE HEAT PUMPS USING VARIABLE COMPOSITION AND CONSTANT COMPOSITION MIXTURES OR PURE REFRIGERANT

Simulation Study on Performance of an Air Source Heat Pump System Combined with Phase Change Thermal Storage Using Alternative Refrigerants

Adaptability and Environmental Impact of CO2/R41 Mixture in Heat Pump Air Conditioning Systems for Electric Vehicles

Energy, Exergy, Economic and Environmental Studies on a Nonflammable Eco-Friendly Mixture for Efficient Heating in Cold Regions

Experimental investigation on the heating performance of a CO2 heat pump system with intermediate cooling for electric vehicles

Performance Evaluation of Transcritical CO2 Desiccant Heat Pumps for Electric Vehicles

Performance Investigation of a Transcritical CO2 Heat Pump Combined with the Terminal of Radiator and Floor Radiant Coil for Space Heating in Different Climates, China

Comprehensive analysis of modified carbon dioxide heat pump systems and determination of operating schemes for residential heating: A multi-objective optimization approach

Hybrid CO2 air source heat pump system integrating with vapor injection and mechanical subcooling technology for space heating of global application: Life cycle techno-energy-enviro-economics assessment

Development and Performance Evaluation of CO2 Automotive Heat Pump System Applied to-20 ℃ Environment

Life cycle energy, emissions and cost evaluation of CO2 air source heat pump system to replace traditional heating methods for residential heating in China: System configurations