Abstract:In this paper, the flotation separation of quartz and feldspar was studied with CaCl 2 as activators and mixed sodium oleate/ dodecylamine (NaOL/DDA) collectors under alkaline condition, and the action mechanism of mixed NaOL/DDA collectors on the quartz and feldspar surfaces were systematically explored. The results of micro-flotation test showed that there were 90.98% quartz and 13.08% feldspar were floated with 0.5 mmol/L CaCl 2 and 2.8 mmol/L mixed NaOL/DDA collectors with molar ratio of 8/1 at pH 10.0. And the artificial mixed minerals flotation manifested these two minerals were able to efficient separation with CaCl 2 and mixed NaOL/DDA collectors at pH 10 ∼ 11. These outcomes indicated that DDA could increase recovery of quartz obviously and reduce about a half dosage of NaOL (from 0.5 mmol/L to 0.25 mmol/L) in flotation under alkaline condition; Meanwhile, mixed NaOL/DDA collectors were able to decreased the flotation separation pH from 12 to 10 on quartz and feldspar. Infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS) results revealed that when NaOL collector was added alone, it could adsorb on activated quartz surface but hardly detected on feldspar surface at pH 10. However, they all were found on both quartz and felspar surface when mixed NaOL/DDA collectors were introduced as collectors. Quartz microcrystal balance with dissipation (QCM-D) experiment confirmed that mixed NaOL/DDA collectors showed a higher adsorption mass and more stable adsorption layer on quartz compared with NaOL was introduced as collector alone. In addition, whether CaCl 2 , NaOL or mixed NaOL/DDA, the adsorption mass on quartz sensor were larger than that on feldspar senor, which might cause difference of hydrophobicity on the surface of quartz and feldspar in flotation. The above experiments showed that the mixed NaOL/DDA collectors can significantly improve hydrophobic difference between quartz and feldspar after activating with CaCl 2 and expand the floated pH range of quartz compared with using NaOL as collector alone, which were efficient reagents to separate quartz and feldspar in flotation.

An Ion-Tolerance Collector AESNa for Effective Flotation of Magnesite from Dolomite

Original Data and Descriptions from Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Effects of Alkyl Ether Amine and Calcium Ions on Fine Quartz Flotation and Its Guidance for Upgrading Vanadium from Stone Coal

Synergistic Effect of Sodium Dodecyl Benzene Sulfonate on Flotation Separation of Magnesite and Dolomite with Sodium Oleate Collector

Effect of Ca(II) on anionic/cationic flotation of magnesite ore

Utilization of a novel bisphosphonic acid surfactant for reverse froth flotation of magnesite and dolomite

Flotation Separation of Magnesite from Dolomite Using Sodium Silicate Modified with Zinc Sulfate as a Selective Depressant

Selective Flotation Separation of Fluorite from Calcite Using Mixed Anionic/cationic Collectors

Flotation separation of magnesite and dolomite regulated by synergistic effect of acid etching and inhibitors

Enhanced flotation of magnesite and dolomite in sodium oleate system using eco-friendly dodecyl dimethyl betaine

Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Study on regulators of purifying magnesite ore by cationic reverse flotation

Adsorption study of potential collector polyoxyethylene ether phosphate on magnesite

In Situ Adsorption of Mixed Anionic/Cationic Collectors in a Spodumene-Feldspar Flotation System: Implications for Collector Design

Selective flotation separation of spodumene from feldspar using a novel mixed anionic/cationic collector NaOL/ND13

Flotation separation of magnesite from dolomite with gellan gum as depressant and its depression mechanism

Adsorption Mechanism of New Mixed Anionic/cationic Collectors in a Spodumene-Feldspar Flotation System

Study on the Reverse Flotation Separation of Smithsonite from Dolomite Using the Saponified 2-(4,4-Dimethylpentan-2-yl)-5,7,7-trimethyloctanoic Acid as a Collector

Flotation behavior of oleate and dodecylamine as mixed collector for recovery of lithium and rubidium from low-grade spodumene tailings: Experiment, characterization and DFT calculation

Adsorption mechanisms of activated surface of quartz and feldspar with mixed NaOL/DDA

The synergetic collecting effect of N-oleoyl sarcosine (N-OSS) and dodecylamine (DDA) on the selective flotation of spodumene from albite