Abstract:With the excessive use of laundry detergents, surfactants from laundry wastewater pose a significant threat to ecological sustainability. Increased attention has been paid to fluorinated amphiphilic copolymers (FACs) that can impart fabrics with water/oil repellency and soil release properties that reduce detergent usage. Depending on their application, FACs are distinguished by surface microphase separations and water-induced surface reconstructions. In this study, a miniemulsion polymerization method was successfully used to synthesize five different hydrophobic-hydrophilic ratio polymer emulsions. An investigation of FACs coating the surface microphase separation and water-induced surface reconstruction was conducted. Hydrophobic-hydrophilic interactions between side chains with significant differences were systematically explained as well. Fluorine-containing components dominate the hydrophobic-hydrophilic interactions, creating highly active molecular chains and water-driven surface reconstruction capabilities. Conversely, in copolymers where hydrophilicity dominates, side chains are significantly separated microscopically, and molecular chains are not mobile. Thus, surface reconstruction is relatively poor under the same conditions. As long as the hydrophobic-hydrophilic ratio is close to equal, two surface phenomena are capable of currents between the two aforementioned scenarios. Further confirmation of the correlation between the application performance of coated fabrics and surface phenomena of films can be obtained from the application tests of fabrics coated with FACs. F75 (the mass content of fluorinated acrylate 13FMA is 75%), whose film has a relatively low surface free energy (gamma(s) = 9.18 mN/m) and the best water-induced surface reconstruction ability (Delta gamma(s) = 1.61 mN/m), can be the optimal choice for the soil release finishing agent (initial soil release rating = 4). FACs on soil release fabric finishes are developed and applied based on this study, which provides theoretical guidance for their development and application.

Water Hardness Effect on the Association and Adsorption of Cationic Cellulose Derivative/anionic Surfactant Mixtures for Fabric Softener Application

Processing effects on bilayer structures formation and rheological behavior of softeners using cationic di(hydrogenated tallow)dimethylammonium chloride aqueous dispersions

Adsorption of a fabric conditioner on cellulose nanocrystals: Synergistic effects of surfactant vesicles and polysaccharides on softness properties

Molecular dynamics study of the effect of inorganic salts on the monolayer of four surfactants at the oil/water interface

Effect of Ionic Strength on the Interfacial and Bulk Properties of Unsymmetrical Bolaamphiphiles

Adsorption of cationic-anionic surfactant mixtures on silica gel/water and silica gel/mineralized water interfaces

Effects of Water Hardness on Selective Flocculation of Diasporic Bauxite

Fabric Softener/Cellulose Nanocrystal Interaction: A Model For Assessing Surfactant Deposition On Cotton

Influence of Hydroxyl Group Content on the Physicochemical Properties of Calcium Lignosulfonate

Effect of Molecular Weight on the Adsorption Characteristics of Lignosulfonates

Synthesis of biodegradable lauric acid ester quaternary ammonium salt cationic surfactant and its utilization as calico softener

Bio-based sulfonated surfactants with high Ca2+ tolerance in detergent formulations

Adsorption of extended anionic surfactants at the water- polymethylmethacrylate interface: The effect of polyoxyethylene groups

Preparation of a New Gel-Type Lignin-Based Cationic Adsorption Resin for Efficient Removal of Ca2+ from Aqueous Solutions.

Influence of cationic alkoxylated amine surfactant on optical and mechanical properties of paper

Properties of Binary Mixture of Cetyl Diphenyl Ether Disulfonate and Linear Alkylbenzene Sulfonate

Study on soften of hard water by chitosan

Synthesis,characterization and Application Performance Study of New Type Aminopolysiloxane Softener

Water and oil repellent properties affected by the crystallinity of fluorocarbon chain in fluorine-silicon containing finishing agent

Design of eco-friendly fabric softeners: Structure, rheology and interaction with cellulose nanocrystals

Surface Microphase Separation and Water-Induced Reconstruction of Fluorinated Amphiphilic Copolymer Coatings for Soil Release Fabrics