Abstract:The synthesis is reported via a one‐step pyrolysis of Ni/Fe based catalyst for syngas electrosynthesis via CO2 and H2O electroreduction. Optimization of the hydrophobicity /ion conductivity of the gas diffusion electrode enables the stable operation of the Ni‐based electrocatalyst for 3 h at −200 mA cm−2 during syngas electrosynthesis for the Fischer–Tropsch process. Simultaneous electroreduction of CO2 and H2O to syngas can provide a sustainable feed for established processes used to synthesize carbon‐based chemicals. The synthesis of MOx/M‐N‐Cs (M = Ni, Fe) electrocatalysts reported via one‐step pyrolysis that shows increased performance during syngas electrosynthesis at high current densities with adaptable H2/CO ratios, e.g., for the Fischer–Tropsch process. When embedded in gas diffusion electrodes (GDEs) with optimized hydrophobicity, the NiOx/Ni‐N‐C catalyst produces syngas (H2/CO = 0.67) at −200 mA cm−2 while for the FeOx/Fe‐N‐C syngas production occurs at ≈−150 mA cm−2. By tuning the electrocatalyst's microenvironment, stable operation for >3 h at −200 mA cm−2 is achieved with the NiOx/Ni‐N‐C GDE. Post‐electrolysis characterization revealed that the restructuring of the catalyst via reduction of NiOx to metallic Ni NPs still enables stable operation of the electrode at −200 mA cm−2, when embedded in an optimized microenvironment. The ionomer and additives used in the catalyst layer are important for the observed stable operation. Operando Raman measurements confirm the presence of NiOx during CO formation and indicate weak adsorption of CO on the catalyst surface.

Synthesis of Tunable Syngas on Cobalt‐Based Catalysts Towards Carbon Dioxide Reduction

Synthesis of Composition-Tunable Syngas from Efficiently Electrochemical Conversion of CO2 over AuCu/CNT Bimetallic Catalyst

Boosting CO Desorption on Dual Active Site Electrocatalysts for CO2 Reduction to Produce Tunable Syngas

Nanoparticle-Assisted Ni–Co Binary Single-Atom Catalysts Supported on Carbon Nanotubes for Efficient Electroreduction of CO 2 to Syngas with Controllable CO/H 2 Ratios

Nanoparticle-Assisted Ni–Co Binary Single-Atom Catalysts Supported on Carbon Nanotubes for Efficient Electroreduction of CO2 to Syngas with Controllable CO/H2 Ratios

Electrochemical Conversion of CO<sub>2</sub> to Syngas with Controllable CO/H<sub>2</sub> Ratios over Co and Ni Single-Atom Catalysts

Electrochemical Conversion of CO <sub>2</sub> to Syngas with Controllable CO/H <sub>2</sub> Ratios over Co and Ni Single‐Atom Catalysts

Electrochemical Conversion of CO2 to Syngas with Controllable CO/H2 Ratios over Co and Ni Single-Atom Catalysts.

A Co3O4-CDots-C3N4 three component electrocatalyst design concept for efficient and tunable CO2 reduction to syngas

Tunable Syngas Formation at Industrially Relevant Current Densities via CO2 Electroreduction and Hydrogen Evolution over Ni and Fe‐derived Catalysts obtained via One‐Step Pyrolysis of Polybenzoxazine Based Composites

Tuning Single Atom-Nanoparticle Ratios of Ni-based Catalysts for Synthesis Gas Production from CO2

Fe-Ni bimetallic composite N-doped carbon catalyst for electrocatalytic reduction of CO 2 to produce efficient and controlled syngas

A bio-inspired O2-tolerant catalytic CO2 reduction electrode

Synthesis of MOF-Derived Hybrids for Efficient Electrocatalytic Reduction of CO2 to Syngas

Tuning Sb Atoms on Cu‐Based Catalysts for Electrochemical Conversion of CO2 to Syngas

Electrochemical conversion of CO2 to syngas with a wide range of CO/H2 ratio over Ni/Fe binary single-atom catalysts

Efficient and steady production of 1 : 2 syngas (CO/H 2 ) by simultaneous electrochemical reduction of CO 2 and H 2 O

N-doped carbon-encapsulated nickel on reduced graphene oxide materials for efficient CO2 electroreduction to syngas with potential-independent H2/CO ratios

Electrochemical Reduction of CO2 into Tunable Syngas Production by Regulating the Crystal Facets of Earth-Abundant Zn Catalyst.

Bi/Zn Dual Single‐Atom Catalysts for Electroreduction of CO 2 to Syngas

Efficient Electrolysis of CO2 Capture Solution to Syngas over Ni‐N‐C Catalyst