Abstract:We introduce magnetophoresis-based microfluidics for sorting biological targets using positive Magnetophoresis (pM) for magnetically labeled particles and negative Magnetophoresis (nM) for label-free particles. A single, externally magnetized ferromagnetic wire induces repulsive forces and is positioned across the focused sample flow near the main channel's closed end. We analyze magnetic attributes and separation performance under two transverse dual-mode magnetic configurations, examining magnetic fields, hydrodynamics, and forces on microparticles of varying sizes and properties. In pM, the dual-magnet arrangement (DMA) for sorting three distinct particles shows higher magnetic gradient generation and throughput than the single-magnet arrangement (SMA). In nM, the numerical results for SMA sorting of red blood cells (RBCs), white blood cells (WBCs), and prostate cancer cells (PC3-9) demonstrate superior magnetic properties and throughput compared to DMA. Magnetized wire linear movement is a key design parameter, allowing device customization. An automated device for handling more targets can be created by manipulating magnetophoretic repulsion forces. The transverse wire and magnet arrangement accommodate increased channel depth without sacrificing efficiency, yielding higher throughput than other devices. Experimental validation using soft lithography and 3D printing confirms successful sorting and separation, aligning well with numerical results. This demonstrates the successful sorting and separating of injected particles within a hydrodynamically focused sample in all systems. Both numerical and experimental findings indicate a separation accuracy of 100% across various Reynolds numbers. The primary channel dimensions measure 100 μm in height and 200 μm in width. N52 permanent magnets were employed in both numerical simulations and experiments. For numerical simulations, a remanent flux density of 1.48 T was utilized. In the experimental setup, magnets measuring 0.5 × 0.5 × 0.125 inches and 0.5 × 0.5 × 1 inch were employed. The experimental data confirm the device's capability to achieve 100% separation accuracy at a Reynolds number of 3. However, this study did not explore the potential impact of increased flow rates on separation accuracy.

Hydrodynamic Assists Magnetophoreses Rare Cancer Cells Separation in Microchannel Simulation and Experimental Verifications

Microdevice for Magnetic Cell Separation Simple Fabrication and Simulation Analysis

Micromagnetophoreses based CTCs Detections in Simple Chip

Magnetic Microfluidic Linear Halbach Array Configuration for Cell Separation

Cell Separation Using Simple Microchip Configuration Experimental and Simulation Analysis.

Hybrid Magnetic Field System with Helmholtz Coils and Magnets for Real-time Circulating Tumor Cell Separation

Design and Development of a Traveling Wave Ferro-Microfluidic Device and System Rig for Potential Magnetophoretic Cell Separation and Sorting in a Water-Based Ferrofluid

Microfluidic Separation of Particles by Synergistic Effect of Geometry-Induced Hydrodynamics and Magnetic Field

Hybrid magnetic and deformability based isolation of circulating tumor cells using microfluidics

Enhanced microfluidic multi-target separation by positive and negative magnetophoresis

In Situ Analysis of Capturing Dynamics of Magnetic Nanoparticles in A Microfluidic System

Computational and experimental microfluidics: Total analysis system for mixing, sorting, and concentrating particles and cells

Microfluidic Approaches for Cancer Cell Separation: Review

A Novel Size-Based Centrifugal Microfluidic Design to Enrich and Magnetically Isolate Circulating Tumor Cells from Blood Cells through Biocompatible Magnetite–Arginine Nanoparticles

Magnetophoresis in Microfluidic Applications: Influence of Magnetic Convection in Hydrodynamic Fields

Magnetically driven microfluidics for isolation of circulating tumor cells

Dual-neodymium magnet-based microfluidic separation device

DESIGN OF A HYBRID-INERTIAL DEVICE FOR THE SEPARATION OF CIRCULATING TUMOR CELLS

Multiphase Ferrofluid Flows for Micro-Particle Focusing and Separation

A Novel Magnetophoretic-Based Device for Magnetometry and Separation of Single Magnetic Particles and Magnetized Cells.

A novel electrophoretic assisted hydrophobic microdevice for enhancing blood cell sorting: design and numerical simulation