Abstract:The interest in wind-assisted ship propulsions (WASPs) is increasing to improve fuel efficiency and to reduce greenhouse gas emissions in ships. A rotor sail, one of the typical WASPs, can provide auxiliary propulsive force by rotating a cylinder-shaped structure based on the Magnus effect. However, due to its huge rotating structure, a meticulous evaluation of the influence on the ship structure and dynamical stability of the rotating structure should be conducted in the design stage. In this respect, an analysis of the rotating structure for a 30 m height and 3 m diameter rotor sail was conducted in this study. First, a 4DOF (four-degree-of-freedom) model was derived to simplify the dynamics of the rotor sail. Using the 4DOF model, natural frequencies for four low-order modes of the rotor sail were calculated, and frequency responses at support points were predicted. Next, a comparison and validation with the finite element model of the rotor sail were carried out. For the 1st and 2nd natural frequencies, a difference of approximately 0.3 Hz was observed between the 4DOF model and the finite element model, confirming the effectiveness of the 4DOF model for low-order modes. In analysis with changes in the bearing supporting stiffnesses, it was verified that lower support bearings have a significant impact on rotor dynamics compared to upper support bearings. Vibration response at the upper support was also confirmed through frequency response analysis caused by imbalance at Thom disk and mid-plate. Additionally, when estimating the eccentricity of the Thom disk as imbalance, a limit of eccentricity error could be set as 24 mm. The presented modeling procedures and analysis results can be references during early design stage of a novel rotor sail structure.

Local Modes Analysis of a Rotating Marine Ship Propeller with Higher Order Harmonic Elements

Study Of The Dynamics Of A Ship Propeller With Higher Order Harmonic Finite Elements

Longitudinal Vibration of Marine Propeller-Shafting System Induced by Inflow Turbulence

Coupled longitudinal-transverse nonlinear dynamics of a marine propulsion shafting—Primary resonance under blade frequency excitation

Hydroelastic analysis of underwater rotating elastic marine propellers by using a coupled BEM-FEM algorithm

Numerical analysis on dynamic behaviors of coupled propeller-shafting system of underwater vehicles

Hydroelastic Analysis of Underwater Rotating Propellers Based on Different Boundary Conditions

Vibration Analysis of a Submarine Elastic Propeller-Shaft-hull System Using FRF-based Substructuring Method

Coupled Vibration Characteristics of a Submarine Propeller-Shaft-hull System at Low Frequency

Coupled Longitudinal-Transverse Dynamics of A Marine Propulsion Shafting under Superharmonic Resonances

Analysis of Dynamic Characteristics of Rotor Sail Using a 4DOF Rotor Model and Finite Element Model

Dynamic Analysis of Ship Stern with 3D Finite Element Method

Fluid–Structure Interaction Vibration Experiments and Numerical Verification of a Real Marine Propeller

Parametric Analysis on Hydroelastic Behaviors of Hydrofoils and Propellers Using a Strongly Coupled Finite Element/panel Method

High-Order Implicit Large-Eddy Simulation of Flow over a Marine Propeller

The Hydroelastic Analysis of Marine Propellers Considering the Effect of the Shaft: Theory and Experiment

Structural-Acoustic Coupling Analysis Of Underwater Submarine Due To Propeller Force

A numerical method for predicting the hydroelastic response of marine propellers

Study on the Self-excited Oscillation of a Propeller-shaft System under Friction Excitation

Dynamic Investigation of the Influence of Propeller on the Vibro-Acoustic Characteristics of Marine Propulsion Systems

Numerical Studies of Propeller Exciting Bearing Forces under Nonuniform Ship’s Nominal Wake and the Influence of Cross Flows