Abstract:Small-angle X-ray scattering (SAXS) and infrared spectroscopy (IR) are employed in a study of chain tilt and disorder in solution-crystallized long alkanes C198H398 and C12D25C192H384C12HD24 in extended and once-folded conformations. The as-grown crystals have chains perpendicular to the lamellar surface, but around 90degreesC they start tilting relative to the layer normal. The tilt increases gradually to reach 35degrees just below melting point. The end-labeled alkane allows independent IR probing of molecular disorder at the deuterated surface layer and in the hydrogenous interior of the crystals. The initially small splitting of the CD2 bending mode doublet and the presence of a singlet component indicated a rough surface in as-grown crystals, with considerable translational disorder. The increase in splitting and decrease in absorbance of the singlet which occur an annealing at progressively higher temperatures showed a steady improvement in translational surface order, concomitant with an increase in chain tilt angle. Thus, it is concluded that the absence of tilt in as-grown crystals is not due to high surface order, as in the case of shorter odd n-alkanes, but rather to high nonequilibrium surface disorder with chain ends or folds protruding out of or sunk beneath the surface. It is also concluded that chain tilt only becomes necessary as the crystal surface becomes translationally more ordered and the crystal-amorphous interface sharpens. IR also demonstrated the reversible increase in conformational disorder in the surface layer with increasing temperature and an almost negligible increase in the crystal interior. The gradual change in tilt angle and the existence of noncrystallographic basal planes is interpreted in terms of translational molecular disorder at the surface. The increased central SAXS scatter during the tilting process indicates the creation of voids associated with ridge formation and corrugation of the lamellae.

Events at the Growth Face As Revealed by Concentration Dependence of Crystallization Rate of Long Alkanes

Growth and nucleation rate minima in long n-alkanes

Crystallization Rate Minima in a Series of n-Alkanes from C194H390 to C294H590

Inversion Of The Temperature-Dependence Of Crystallization Rates Due To Onset Of Chain Folding

New Trends in Polymer Crystallization Studies: Part I ‐ from Alkanes to Polyethylene: the Onset of Chain Folding in Polymer Crystallization

Isothermal refolding in crystals of long alkanes in solution. I. Effect of surface ‘self-poisoning’

Dilution wave and negative-order crystallization kinetics of chain molecules.

The Growth of Polymer Crystals at the Transition from Extended Chains to Folded Chains

Time-Resolved Synchrotron X-Ray Study Of Chain-Folded Crystallization Of Long Paraffins

Effect of Crystallization Conditions on the Shape of Polymer Single Crystals: Experimental and Theoretical Approaches

Formation of the Extended Chain Crystals and Once Folded Crystals of Linear Chain Molecules

Step Initiation and Propagation Rate Minima in Solution Crystallization of Five Long Alkanes

Complex Layered Nanostructures in Crystalline and Semicrystalline Ultralong Alkanes

In Situ Solution Crystallization Study of N-C246h494: Self-Poisoning and Morphology of Polymethylene Crystals

Chain Tilt and Surface Disorder in Lamellar Crystals. A FTIR and SAXS Study of Labeled Long Alkanes

The Crystallization of Ultralong Normal Paraffins: the Onset of Chain Folding.

Understanding Self-Poisoning Phenomenon in Crystal Growth of Short-Chain Polymers.

Isothermal Refolding in Crystals of Long Alkanes in Solution. II. Morphological Changes Accompanying Thickening

Nonintegral and integral folding crystal growth in low-molecular mass poly (ethylene oxide) fractions. III. Linear crystal growth rates and crystal morphology

Continuum model for mesh crystallization.

Structure and Formation of Noninteger and Integer Folded-Chain Crystals of Linear and Branched Monodisperse Ethylene Oligomers