Abstract:An experimental investigation has been performed, studying bubble phase and emulsion phase behavior in a gas-solid fluidized bed using non-invasive optical techniques. The fluidized bed setup, consisting of two pseudo-2D beds, was operated at various conditions, varying both the bed aspect ratio and the superficial gas velocity. The bed consists of Geldart B glass beads. Experiments were performed by recording images of the bed with a high-speed camera. The images were analyzed by commercial (PIV) and in-house developed software (DIA). Particle Image Velocimetry has been used to analyze the behavior of the emulsion phase. A method has been implemented to verify that the image recording scheme yielded reproducible time-averaged flow patterns. Also, a vector field stitching program was delivered. In addition, a method is developed to correct for raining particles through bubbles, which severely influence the time-averaged emulsion phase flow pattern. The correction algorithm showed an obvious upward particle flow, whereas the raw PIV results barely yielded any upflow of particles at all. Even after correction, upflow of particles is less pronounced than the downflow. Adaptations of the correction algorithm have been proposed to solve this issue. Corrected time-averaged emulsion phase flow patterns were obtained at 28 different operating conditions. It was shown that the upflow of particles is found along the bubble path, from the lower wall region to the top-center region in the bed. The velocity of the particles increased severely with increasing gas flow. A Digital Image Analysis (DIA) algorithm has been developed, capable of measuring bubble properties from an image series. The program was validated and yields accurate and reproducible results. The DIA program was used to investigate relations for bubble size, velocity and aspect ratio. A theoretical relation, predicting the bubble diameter in a pseudo-2D bed was adapted to include the bed width. The velocity of the bubbles in a pseudo-2D bed can be described as ub = KB p gdb, in which KB is a value between 0.6 and 0.7. Moreover, a relation between the bubble aspect ratio and the rise velocity has been observed. An attempt has been made to describe the bubble-particle phase interaction. By accounting for the average bubble rise velocity, diameter, aspect ratio and frequency of bubbles, it was shown that the trend of the lateral velocity distribution at a single height of the emulsion phase can be predicted. More studies are required to adapt the proposed correlation to yield the expected absolute emulsion phase velocity.

Experimental Study of Liquid-Solid Two Phase Flow over a Step Using PIV

Unsteady Numerical Analysis of the Liquid-Solid Two-Phase Flow Around a Step Using Eulerian-Lagrangian and the Filter-Based RANS Method

Experimental and Numerical Investigations of Film Flow Behaviors in Resonance Section over Corrugated Plates

Experimental and numerical simulation of flow over stepped spillways

Experimental study and numerical simulation of water-sand two-phase flow in fracture network

A Piv System for Two-Phase Flow with Nanoparticles

Experimental and Numerical Studies of Water–Sand Flow in Fractured Porous Media

Flow characteristics and energy dissipation over stepped spillway with various step geometries: case study (steps with curve end sill)

Unseeded Large Scale PIV measurements accounting for capillary-gravity waves phase speed

PIV in stratified gas-liquid flow in a horizontal pipe using water droplets as tracers in the gas-phase

Liquid/solid flow field in a centrifugal pump with different impeller blade types by PIV

Investigation of turbulent flow induced by particle sedimentation using RIM-PIV

Experimental Study on the Effects of Particle–wall Interactions on VLSM in Sand-Laden Flows

Experimental investigation on the multiphase flow characteristics of oblique water entry of semi-closed cylinder

Experiment and modeling of liquid-phase flow in a venturi tube using stereoscopic PIV

Application of VOF and k-ε turbulence model in simulation of flow over a bottom aerated ramp and step structure

Two-Phase Stereo-PIV measurement techniques for Gas-Liquid Two-Phase flow — Methodology and validation

Development of an experimental method to investigate the hydrodynamics in a fluidizedbed using PIV and DIA

NUMERICAL SIMULATION OF LAMINAR SOLID-LIQUID TWO-PHASE FLOW IN STIRRED TANKS

PIV Experimental Investigation on the Flow in a Model of Closed Pump Sump

Instantaneous Investigation of Gas-Solid Two-Phase Free Jet Flow