Abstract:Ordinary Portland cement (OPC) is the most common curing agent for solidification/stabilization (S/S) of fly ash (FA), however, the treatment is not efficient. This study aims to investigate the S/S of FA with the modified calcium aluminate cement (CAC) as a binder. The modified CAC was obtained by adding sodium dihydrogen phosphate (NaH 2 PO 4 ), an inorganic chemical agent, and sodium diethyl dithiocarbamate (DDTC), an organic chemical agent, into CAC. Toxicity characteristic leaching procedure and unconfined compressive strength (UCS) test were carried out to evaluate the treatment effect of the proposed binder. The sequential extraction procedure (SEP), X-ray diffraction and scanning electron microscopy (SEM) were used to study the chemical speciation , mineralogical characterization and microstructure of the solidified/stabilized FA. The treatment results of pure CAC and OPC showed that the immobilizing efficiency of CAC was much higher than that of OPC. When curing with 10% CAC and 1% DDTC, the leaching concentrations of Cd, Pb and Zn decreased to 0.06, 0.12 and 18.95 mg/L, respectively. With the combination of 10% CAC and 0.5% DDTC + 0.5% NaH 2 PO 4 , the leaching concentrations of Cd, Pb and Zn were 0.12, 0.16 and 10.21 mg/L, respectively. The regulated leaching limits can be met under both of the above combinations. The UCS of the solidified body was 3.02 MPa under the combination of CAC + NaH 2 PO 4 + DDTC, which was much higher than the 1.34 MPa of the CAC + DDTC combination. SEP shows that most unstable forms of Cd, Pb and Zn in FA were converted to stable forms after the treatment by modified CAC. The immobilization mechanisms of the proposed binder included encapsulation of heavy metals and the formation of heavy metal complexes or precipitate. The CAC hydration products, the precipitate and complexes reduced the pores in FA particles and therefore reduced the leachability of heavy metals. This study demonstrated the effectiveness of the proposed modified CAC as a binder for FA treatment. As NaH 2 PO 4 is inexpensive than DDTC, the scheme of CAC + NaH 2 PO 4 + DDTC is recommended.

Stabilization/Solidfication of Cadmium in Municipal Solid Waste Incineration Fly Ash by Using Cemented Backfill Agent

A Novel Approach to Heavy Metal Immobilization in Municipal Solid Waste Incineration Fly Ash: Investigating the Use of Chicken Eggshell Waste and CaO Addition

Utilization of Cow Bone Waste and Calcium Oxide for the Solidification and Stabilization of MSWI Fly Ash: Towards Sustainable Practices

Measurements of geotechnical properties of municipal solid waste incineration fly ash stabilized by chemical reagents

Leaching Characteristics of Heavy Metals During Cement Stabilization of Fly Ash from Municipal Solid Waste Incinerators

Utilization of Mechanochemically Pretreated Municipal Solid Waste Incineration Fly Ash for Supplementary Cementitious Material

The Effects of Water Washing on Cement-Based Stabilization of Mwsi Fly Ash

Characteristics of the cement-solidified municipal solid waste incineration fly ash

Study of Incineration Fly Ash Dual Stabilization and Utilization

Immobilization mechanisms of cr and pb in cement solidified municipal solid waste incineration fly ash

Solidification/Stabilization of Waste Incineration Fly Ash by Modified Calcium Aluminate Cement

The cementitious properties of alkali-activated municipal solid waste incineration fly ash-phosphorus slag-secondary aluminum dross matrix composites and the mechanism of solidification of heavy metals

Risk Assessment of Lead and Cadmium Leaching from Solidified/stabilized MSWI Fly Ash under Long-Term Landfill Simulation Test.

Review on Cement Stabilization/Solidification of Municipal Solid Waste Incineration Fly Ash

Effect of long-term dry–wet circulations on the Solidification/stabilization of Municipal solid waste incineration fly ash using a novel cementitious material

Experimental Study on Properties and Cement Solidification of Municipal Solid Waste Incineration Fly Ash

Solidification/stabilization of municipal solid waste incineration fly ash using uncalcined coal gangue–based alkali-activated cementitious materials

Solidification/stabilisation of Pb (II) and Cu (II) containing wastewater in cement matrix

Intermediate-calcium Based Cementitious Materials Prepared by MSWI Fly Ash and Other Solid Wastes: Hydration Characteristics and Heavy Metals Solidification Behavior

Chemical stabilization of MSW incinerator fly ashes.

Investigation of Mechanochemically Treated Municipal Solid Waste Incineration Fly Ash as Replacement for Cement