Abstract:In this work, SrBi4Ti4O15 (SBT) high-temperature piezoelectric ceramics with the addition of different oxides (Gd2O3, CeO2, MnO2 and Cr2O3) were fabricated by a conventional solid-state reaction route. The effects of oxide additives on the phase structures and electrical properties of the SBT ceramics were investigated. Firstly, X-ray diffraction analysis revealed that all these oxides-modified SBT ceramics prepared presented a single SrBi4Ti4O15 phase with orthorhombic symmetry and space group of Bb21m, the change in cell parameters indicated that these oxide additives had diffused into the crystalline lattice of SBT and formed solid solutions with it. The SBT ceramics with the addition of MnO2 achieved a high relative density of up to 97%. The temperature dependence of dielectric constant showed that the addition of Gd2O3 could increase the TC of SBT. At a low frequency of 100 Hz, those dielectric loss peaks appearing around 500 °C were attributed to the space-charge relaxation as an extrinsic dielectric response. The synergetic doping of CeO2 and Cr2O3 could reduce the space-charge-induced dielectric relaxation of SBT. The piezoelectricity measurement and electro-mechanical resonance analysis found that Cr2O3 can significantly enhance both d33 and kp of SBT, and produce a higher phase-angle maximum at resonance. Such an enhanced piezoelectricity was attributed to the further increased orthorhombic distortion after Ti4+ at B-site was substituted by Cr3+. Among these compositions, Sr0.92Gd0.053Bi4Ti4O15 + 0.2 wt% Cr2O3 (SGBT-Cr) presented the best electrical properties including TC = 555 °C, tan δ = 0.4%, kp = 6.35% and d33 = 28 pC/N, as well as a good thermally-stable piezoelectricity that the value of d33 was decreased by only 3.6% after being annealed at 500 °C for 4 h. Such advantages provided this material with potential applications in the high-stability piezoelectric sensors operated below 500 °C.

High-temperature and Long-Term Stability in Co/Sb-codoped (Bi0.5na0.5)tio3-Based Electrostrictive Ceramics

Enhanced Electric-Field-induced Strain in 0.7bi(1−x)smxfeo3–0.3batio3 Lead-Free Ceramics

Structure Evolution and Electrostrictive Properties in (bi0.5na0.5)0.94ba0.06tio3–m2o5 (M = Nb, Ta, Sb) Lead-Free Piezoceramics

Phase Diagram and Electrostrictive Properties of Bi0.5Na0.5TiO3–BaTiO3–K0.5Na0.5NbO3 Ceramics

Electric Field-Induced Large Strain in Ni/Sb-co Doped (bi0.5na0.5) TiO3-Based Lead-Free Ceramics

Electric Field-Induced Large Strain in Ni/Sb-co Doped (Bi 0.5 Na 0.5 ) TiO 3 -Based Lead-Free Ceramics

Lead-free electrostrictive (Bi 0.5 Na 0.5 )TiO 3 –(Bi 0.5 K 0.5 )TiO 3 –(K 0.5 Na 0.5 )NbO 3 ceramics with good thermostability and fatigue-free behavior

Normal-relaxor Ferroelectric Phase Transition Induced Morphotropic Phase Boundary Accompanied by Enhanced Piezoelectric and Electrostrain Properties in Strontium Modulated Bi0.5K0.5TiO3 Lead-Free Ceramics

Temperature-Dependent Electrical Properties of 0.94Bi<sub>0.5</sub>Na<sub>0.5</sub>TiO<sub>3</sub>-0.06BaTiO<sub>3</sub>Ceramics

Effects of Oxide Additives on the Phase Structures and Electrical Properties of SrBi4Ti4O15 High-Temperature Piezoelectric Ceramics

Temperature‐independent large strain with small hysteresis in Sb‐modified BNT‐based lead‐free ceramics

Large electrostrictive effect and dielectric properties of (K0.5Na0.5)NbO3-BaZrO3 ceramics

Large Strain of Lead-Free Bismuth Ferrite Ternary Ceramics at Elevated Temperature

Temperature-Dependent Electrical Properties Of 0.94bi(0.5)Na(0.5)Tio(3)-0.06batio(3) Ceramics

Phase structure and electrical properties of (Ba1/2Sr1/2)2+ modified high Curie temperature CaBi2Nb2O9‐based ceramics

Giant electromechanical strain response in lead‐free SrTiO3‐doped (Bi0.5Na0.5TiO3–BaTiO3)–LiNbO3 piezoelectric ceramics

Phase transition behavior and high electrostrictive strains in Bi(Li0.5Nb0.5)O3-doped lead magnesium niobate-based solid solutions

Thermally-stable Large Strain in Bi(Mn0.5Ti0.5)O3 Modified 0.8Bi0.5na0.5tio3-0.2Bi0.5k0.5tio3 Ceramics

Morphotropic Phase Boundary And Electric Properties In (1-X)Bi(0.5)Na(0.5)Tio(3-)Xbicoo(3) Lead-Free Piezoelectric Ceramics

Effect of W/Cr co-doping on electrical properties of Ca0.94Ce0.06Bi4Ti4O15 high-temperature piezoceramics

High electrostrictive properties and energy storage performances with excellent thermal stability in Nb-doped Bi0.5Na0.5TiO3-based ceramics