Investigation of droplet boiling on superhydrophilic CuO multiscale hierarchical structured surfaces

Pradyumna Kodancha,Siddhartha Tripathi,Pradeep Kumar Sow,Vadiraj Hemadri
DOI: https://doi.org/10.1016/j.ijthermalsci.2024.109057
IF: 4.779
2024-04-07
International Journal of Thermal Sciences
Abstract:This work presents the experimental investigation of droplet boiling characteristics on superhydrophilic surfaces. These surfaces are prepared on a copper substrate, and the boiling characteristics are studied and compared with the bare copper surface. Two types of superhydrophilic surfaces exhibiting needle-like (CuO-1) and sheet-like (CuO-2) nanostructures are prepared by the chemical etching oxidation technique. The hierarchical surface structures are characterized by carrying out SEM and XRD analysis. We employ high-speed imaging along with temperature measurement to characterize the heat transfer phenomenon. The surface temperature varies from 100 °C to 190 °C, and the Weber number is maintained constant at 2.78, corresponding to the gentle droplet impact regime. The effectiveness in the heat transfer performance of the different surfaces is characterized by measuring the critical heat flux (CHF) and the Leidenfrost point (LFP), and it is correlated with the surface properties viz. roughness, wettability, and porosity. The superhydrophilic surface alteration reduces the contact angle by about 99.7% compared to the bare surface. This reduction in contact angle corresponds to an increase in Critical Heat Flux (CHF) by 69.95% for CuO-1 and 47.17% for CuO-2, respectively, compared to bare copper. It is also seen that the LFP is delayed on the superhydrophilic surfaces, with an increase in the LFP temperature by 16.67% and 14.28% for CuO-1 and CuO-2 coatings, respectively. The effect of structures on the atomization and formation of secondary droplets is also presented. We report the contact coefficient ( k w ) for superhydrophilic surfaces for the first time, which is helpful in the theoretical prediction of CHF. These results show that significant improvement in heat transfer can be obtained in spray cooling and hot spot cooling applications without resorting to sophisticated microfabrication techniques.
engineering, mechanical,thermodynamics
What problem does this paper attempt to address?