Abstract:An optical sensor employing tunable diode laser absorption spectroscopy with wavelength modulation and 2f harmonic detection was designed, prototyped, and tested for applications in quantifying methane emissions from vent sources in the oil and gas sector. The methane absorption line at 6026.23 cm−1 (1659.41 nm) was used to measure both flow velocity and methane volume fraction, enabling direct measurement of the methane emission rate. Two configurations of the sensor were designed, tested, and compared; the first used a fully fiber-coupled cell with multimode fibers to re-collimate the laser beams, while the second used directly irradiated photodetectors protected by Zener barriers. Importantly, both configurations were designed to enable measurements within regulated Class I / Zone 0 hazardous locations, in which explosive gases are expected during normal operations. Controlled flows with methane volume fractions of 0 to 100% and a velocity range of 0 to 4 m/s were used to characterize sensor performance at a 1 Hz sampling rate. The measurement error in the methane volume fraction was less than 10,000 ppm (1%) across the studied range for both configurations. The short-term velocity measurement error with pure methane was <0.3 m/s with a standard deviation of 0.14 m/s for the fiber-coupled configuration and <0.15 m/s with a standard deviation of 0.07 m/s for the directly irradiated detector configuration. However, modal noise in the multimode fibers of the first configuration contributed to an unstable performance that was highly sensitive to mechanical disturbances. The second configuration showed good potential for an industrial sensor, successfully quantifying methane flow rates up to 11 kg/h within ±2.1 kg/h at 95% confidence over a range of methane fractions from 25−100%, and as low as ±0.85 kg/h in scenarios where the source methane fraction is initially unknown within this range and otherwise invariant.

Off-axis Integrated Cavity Output Spectroscopy for Real-Time Methane Measurements with an Integrated Wavelength-Tunable Light Source

Near-Infrared Dual-Range Methane Sensor Using the OAIC-HC Mode Based on VMD-SG-Assisted Optical Noise Suppression

Frequency division multiplexing and wavelength stabilized 2f/1f wavelength modulation spectroscopy for simultaneous trace CH4 and CO2 detection

Re-injection off-axis integrated cavity output spectroscopy for the simultaneous detection of N2O, H2O and CO with a mid-infrared QCL laser

Measurement of CO2 by Wavelength Modulated Reinjection Off-Axis Integrated Cavity Output Spectroscopy at 2 μm

TDLAS–WMS based near-infrared methane sensor system using hollow-core photonic crystal fiber as gas-chamber

Monolithic Mid-IR Methane Gas Sensor with Waveguide-Integrated Detector

CH4/C2H6 dual-gas sensing system based on wavelength modulation spectroscopy using a single near infrared laser

Simultaneous atmospheric CH 4 , CO 2 and O 2 detection using fiber-optic switch (FOS)-based time-division multiplexed NIR laser long optical path absorption spectroscopy

On-chip mid-infrared silicon-on-insulator waveguide methane sensor using two measurement schemes at 3.291 μm

On-chip Long-Wave Infrared Gas Sensor Based on Subwavelength Grating Waveguide

Intracavity trace molecular detection with a broadband mid-IR frequency comb source

A Dual-Laser Sensor Based on Off-Axis Integrated Cavity Output Spectroscopy and Time-Division Multiplexing Method

Vehicle-Deployed Off-Axis Integrated Cavity Output Spectroscopic CH4/C2H6 Sensor System for Mobile Inspection of Natural Gas Leakage

Ppb-level Methane Detection Sensitivity Based on a Homemade Raman Fiber Amplifier and Differential Photoacoustic Technology

Methane sensing in the mid-IR using short wave IR photon counting detectors via non-linear interferometry

[A Methane Gas Sensor Based on Mid-Infrared Quantum Cascaded Laser and Multipass Gas Cell]

Mixed-gas CH4/CO2/CO detection based on linear variable optical filter and thermopile detector array

A Wavelength Modulation Spectroscopy-Based Methane Flux Sensor for Quantification of Venting Sources at Oil and Gas Sites

Sensitive Carbon Monoxide Detection Based on Light Induced Thermoelastic Spectroscopy with a Hollow Waveguide and 2.3 Μm Diode Laser

Miniature low-power IR monitor for methane detection