Abstract:Industrial practice has confirmed that decreasing the bed material size substantially diminishes nitrogen oxide (NOx) emissions in coal-fired circulating fluidized bed (CFB) boilers. This reduction allows for compliance with the stringent ultra-low emissions standard (NOx < 50 mg/Nm(3)@6%O-2, dry) proposed by the Chinese government, all without the need for supplementary denitrification devices. Consequently, it becomes essential to delve into the mechanisms through which particle size, as a gas-solid flow characteristic, directly affects the chemical reaction dynamics within the coal combustion process. Due to the difficulty of field tests, this paper employs the Eulerian-Eulerian numerical method suitable for wide particle size distributions to investigate the impact of bed material particle size on gas-solid flow and NOx concentration. Furthermore, the generalized QC-EMMS drag model is utilized to predict the heterogeneous flow across varying particle size conditions. Industrial test data validated the simulation accuracy, with prediction errors of bed pressure drop, temperature, and NOx emission concentration ranging from 5 % to 8.1 %. The analysis revealed that the particle concentration distribution heterogeneity decreases as the particle size diminishes. The variation trends of NOx with particle size exhibit distinct differences between the lower dense phase region and the upper dilute phase region within the bed. For finer bed material particles, the high NOx concentration generated in the dense phase region experiences a more thorough reduction in the dilute phase region. Through the analysis of material concentration and reaction rate, it is believed that this phenomenon is related to the increased catalytic effect of fine ash particles in the dilute phase region, that is, the reduction in particle size leads to an increase in catalytic specific surface area, enhancing NOx reduction, thus achieving ultra-low emissions at the outlet. These research results provide theoretical support for further development of ultra-low emission coal-fired CFB boilers.

An Experimental Study on the Characteristics of NOx Distributions at the SNCR Inlets of a Large-Scale CFB Boiler

Full-Scale Numerical Investigation of a Selective Noncatalytic Reduction (SNCR) System in a 100 MW Utility Boiler with Complex Chemistry and Decoupling Approach

Numerical Simulation and Optimization of SNCR System for CFB Boilers

Cost-Efficient Nitrogen Oxides Control by a Hybrid Selective Noncatalytic Reduction and Selective Catalytic Reduction System on a Utility Boiler

Numerical Study of SNCR Process in Coal-Fired Boiler with Large Capacity

Industrial Experiment on NO x Reduction by Urea Solution Injection in the Fuel-Rich Zone of a 330 MW Tangentially Pulverized Coal-Fired Boiler

Experimental Research on SNCR Applied in Power Plant Boiler: Impact of Temperature and Urea Solution Injection Volume Flow Rate

An Experimental Study on N2O Reduction over Circulating Ashes of CFB Boilers

A Pilot-Scale Test Facility of 500 Kwth for Industrial Cfb Boilers on Low Nitrogen Combustion-Discussion of Design, Experiment, and Economic Analysis

DeNOx technology selection and optimal design of SNCR system for a 300MWe CFB boiler

Eulerian Investigation of the Mechanism of Ultra-low NOx Emissions from CFB Boilers with Finer Bed Material

Denitration Simulation of SNCR System Nozzles at Different Layout Positions in Coal Powder Boilers

The application of RANS CFD for design of SNCR technology for a pulverized coal-fired boiler

Experimental Research on SNCR Applied in 125 MW Power Plant Boiler

The Theory and Practice of Nox Emission Control for Circulating Fluidized Bed Boilers Based on the Re-Specification of the Fluidization State

Ultradian and circadian rhythms in the plasma concentration of cortisol in sheep.

Highly Efficient and Economical Nitrogen Oxides Controlled by an In‐furnace Urea Solution Pyrolysis Coupled with SCR System for a Coal‐fired Utility Boiler

Emission characteristics test of SO2,NOx and dust from a 350 MW super-critical circulating fluidized bed boiler

Low NO_x Combustion Tests on a 200MW Coal-Water Slurry Fired Boiler

Prediction and Minimization of NOx Emission in a Circulating Fluidized Bed Combustor: Improvement of Bed Quality by Optimizing Cyclone Performance and Coal Particle Size

Application of Ultra-Low NOx Emission Control for CFB Boilers Based on Theoretical Analysis and Industrial Practices