Abstract:Al/granular MnO2 and Al/rod MnO2 thermite samples were prepared to investigate the effects of different morphologies of MnO2 on the thermal properties and combustion behavior of nano-Al/MnO2 thermite. The morphology and thermal properties of the thermite were characterized by field emission scanning electron microscopy (FE-SEM), x-ray diffractometry (XRD), and differential scanning calorimetry (DSC). DSC results show that the Al/rod MnO2 releases 1274.39 J·mol−1 heat, which is 292.58 J·mol−1 more than the Al/granular MnO2. The initial reaction temperature of Al/rod MnO2 is 567.39 °C, which is delayed by 17.39 °C versus 550 °C of Al/granular MnO2. Non-isothermal thermodynamic analysis was used to measure the activation energy of Al/rod MnO2 to be 234.36 kJ·mol−1, which is 46.53 kJ·mol−1 higher than that of Al/granular MnO2. This corresponds to an increase in the ignition temperature in the DSC curve and indicating a higher safety profile. In the open burning experiment, the burning time of Al/granular MnO2 was longer and sparks sputtered around the flame. The Al/rod MnO2 has a large combustion flame and a fast combustion rate. The light intensity peaks of the two groups of samples are close in the light intensity test. The light intensity existence time of Al/rod MnO2 is 0.0146 s, which is 0.094 s shorter than Al/granular MnO2. This shows that the combustion rate of Al/rod MnO2 is much faster than that of Al/granular MnO2. The closed-tube combustion experiment shows that the combustion wave velocity of Al/rod MnO2 increases first and then decreases; the maximum wave velocity reaches 339.6 m·s−1, and Al/granular MnO2 cannot self-propagate combustion in the microporous environment. In the constant volume combustion experiment, the peak combustion pressure of Al/rod MnO2 is 0.938 Mpa, and the peak value of Al/granular MnO2 combustion pressure is 0.581 Mpa; the difference is obvious. This shows that the rod MnO2 gas production performance is better. According to the duration of the pressure peak, the burning speed of Al/rod MnO2 in the light intensity test is confirmed again to be much faster than that of Al/granular MnO2. The Al/rod MnO2 is better than Al/granular MnO2 in thermal and combustion performance and is also safer. This provides a basis for future performance and safety research on aluminothermic materials.

Catalytic Effect of Mn Particle Size on Thermal Decomposition of Sodium Chlorate in Oxygen Generators

Effect of MnO2 morphology on the thermal properties and combustion behavior of nano-Al/MnO2 thermite

Effect of Crystal Phase of MnO2 with Similar Nanorod‐Shaped Morphology on the Catalytic Performance of Benzene Combustion

Effect of MnO2 Morphology on Its Catalytic Performance in Lean Methane Combustion

Catalytic Effect of Supported Nanometer NiO on the Thermal Decomposition of Ammonium Perchlorate by DSC/TG-MS

Effect of Calcination Temperature on Structural Properties and Catalytic Soot Combustion Activity of MnOx/wire-mesh Monoliths

Effect of Jahn−Teller Distortion in La0.5Sr0.5MnO3 Cubes and Nanoparticles on the Catalytic Oxidation of CO and CH4

Catalytic Effect of Mnfe2o4 on Dehydrogenation Kinetics of Naalh4-Mgh2

Lattice oxygen behaviors of Mn-based catalytic oxygen carriers and sustainable oxidative coupling of methane in chemical-looping scheme

Effect of the Crystal Plane Figure on the Catalytic Performance of MnO2for the Total Oxidation of Propane

Effects of heat treatment on the physical and electrochemical performance of γ-MnO2

The High Activity and Stability of La0.5ba0.5mno3 Nanocubes in the Oxidation of Co and Ch4

Oxidization and Reduction Kinetics of a Manganese Oxygen Carrier Granulated with the Spray Drying Method at a Tonnage Scale for Chemical Looping Combustion

Preparation of Nanometer NiO/MgO and Its Catalytic Performance for Thermal Decomposition of Ammonium Perchlorate

Surface structure effects in nanocrystal MnO2 and Ag/MnO2 catalytic oxidation of CO

Catalytic ozonation of dichloromethane at low temperature and even room temperature on Mn-loaded catalysts

Efficient monolithic MnOx catalyst prepared by heat treatment for ozone decomposition

Catalytic Behavior of Hydrothermally Synthesized La0.5Sr0.5MnO3 Single-Crystal Cubes in the Oxidation of CO and CH4

Revealing the strong interaction effect of MnO nanoparticles and Nb2O5 supports with variable morphologies on catalytic propane oxidation

Effect of MnO2 Polymorphs' Structure on Low-Temperature Catalytic Oxidation: Crystalline Controlled Oxygen Vacancy Formation.

Effect of Calcination Temperature on the Structure and Performance of Mn/Al2O3-TiO2 Catalyst in the Catalytic Oxidation of NO