Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Experimental Investigation into Leaf-Vein-Like Fractal Structure Applied to Evaporation of Vapor Chamber

Comparative research on the heat transfer efficiency of evaporators with different structures used in a large quick-freeze plant

Experimental Study on High-efficient Evaporator in Large Quick-freeze Equipment

Experimental study on high efficiency evaporator in a large quick-freeze equipment

Performance Study of a Leaf-Vein-like Structured Vapor Chamber

Visualization experimental study on the boiling characteristics of vapor chamber evaporator surface with different heat sources

Enhanced evaporation performance on a novel microstructured surface with vertical dimension gradient

Experimental Investigation on the Thermal Performance of a Large-Size Aluminum Vapor Chamber for Multi-Point Heat Sources

A Novel Vapor Chamber and Its Performance

Droplet Evaporation to Boiling in Van Der Waals Fluid

An improved vapor chamber with enhanced two-phase transport by using structured surfaces

Vapor chamber with two-layer liquid supply evaporator wick for high-heat-flux devices

Analytical Study of Impact of the Wick’s Fractal Parameters on the Heat Transfer Capacity of a Novel Micro-Channel Loop Heat Pipe

Thermal Performance of a Liquid-cooling Assisted Thin Wickless Vapor Chamber

Experimental and Numerical Investigation on Heat Transfer Performance of Water Evaporators with Different Channels and Fin Structures in a Sub-Atmosphere Environment

Study on the thermal performance of pulmonary vascular-inspired grooved vapor chamber

Experiments on a Novel Vapor Chamber

An analysis of flow characteristics during ethanol natural evaporation in capillary tubes with varying diameters

Experimental Investigation on Ultra-Thin Vapor Chamber with Composite Wick for Electronics Thermal Management

Experimental Investigation on Heat Transfer Enhancement of Phase Change Materials by Fractal Fins

Numerical analysis on heat transfer characteristics of a multi-vapor channel vapor chamber with novel ultra-thin composite wick