Abstract:Objective:To recover organic nitrogen from chitin-alkali effluent by acid and alkali resistant Nanofiltration membrane(NFM),the different operating conditions including the temperatures and the trans-membrane pressures(TMPs) were explored,which have taken an important role on the permeation fluxes and the rejection of the target.By that,membrane main operation parameters and Nanofiltration concentrated mass transfer analysis were established.Methods:The optimal TMP and the optimal temperature were determined by comparing the change of the fluxes and the rejections under the different operating conditions,under which the same alkali liquors in the equivalent volume were circulated for eight hours the NFM.After that,the alkali effluent was concentrated for the recovery of the organic nitrogen by the NFM under that certain conditions.The mass-transfer during the Nanofiltration of the effluent was analyzed via the Matlab simulating the parameters of the NFM basing on the Teorell-Meyer-Sievers(TMS) model and the Steric-Hindrance Pore(SHP) model.Results:The optimum operating condition was that the TMP was fixed at 30 bar(3.0 MPa) and the circulating temperature is around 40 ℃,which benefited the enrichment of the peptides and offered a faster flux than other conditions.Apart from that,the rejections of the peptides increased over the time.Finally,the penetration rate of the organic nitrogen was just 5.92%.The pore diameter of the stained NFM narrowed compared to the clean NFM,which was on the basis of the TMS model.And the surface charge density of the NFM got dense during the Nanofiltration,which was based on the SHP model.Conclusion:The membrane pore shrunk slowly and the membrane surface charge enriched during the concentration by the NFM,which might enlarged the rejections of the peptides.

Salt Removal of High-Viscosity Ampho-Surfactant Using Nanofiltration Membrane

High Flux Nanofiltration Membranes Prepared by Dynamic Self-Assembly of PSS-co-MA and PAH for CuCl2 Removal

High-flux Reverse Osmosis Membranes Incorporated with NaY Zeolite Nanoparticles for Brackish Water Desalination

Selective Separation of Chloride and Sulfate by Nanofiltration for High Saline Wastewater Recycling

A Separation and Desalination Process for Farmland Saline-Alkaline Water

Separation performance of a nanofiltration membrane influenced by species and concentration of ions

Lithium Concentration from Salt-Lake Brine by Donnan-Enhanced Nanofiltration.

Preparation of SGO-modified Nanofiltration Membrane and Its Application in SO42 − and Cl− Separation in Salt Treatment

Removal of Heat-Stable Salts from Lean Amine Solution Using Bipolar Membrane Electrodialysis

Converting softening nanofiltration brine into high-solubility liquid salts (HSLS) via electrodialysis metathesis: Effect of membrane type

The Mass-Transfer Analysis during the Chitin-Alkali Effluent Filtrated by Acid-Alkali Resistant Nanofiltration Membrane

DiaNanofiltration-based process for effective separation of Li+ from the high Mg2+/Li+ ratio aqueous solution

Separation performance and fouling analyses of nanofiltration membrane for lithium extraction from salt lake brine

Comparison of the Mg2+-Li+ Separation of Different Nanofiltration Membranes

Scalable nanofiltration membranes with sharpened pore distribution and enhanced negativity for mono/divalent anion separation

Role of Backwash Water Composition in Alleviating Ultrafiltration Membrane Fouling by Sodium Alginate and the Effectiveness of Salt Backwashing

Separation of Saccharides and Salts by Using Nanofiltration Membranes

Nanofiltration Membranes with Salt-Responsive Ion Valves for Enhanced Separation Performance in Brackish Water Treatment: A Battle against the Limitation of Salt Concentration

A Homogeneous Polysulfone Nanofiltration Membrane with Excellent Chlorine Resistance for Removal of Na2SO4 from Brine in Chloralkali Process

Developing a reclamation strategy for softening nanofiltration brine: A scaling-free conversion approach via continuous two-stage electrodialysis metathesis

Low-temperature Regulated Interfacial Polymerization of Nanofiltration Membrane for Efficient Li+/Mg2+ Separation