Abstract:Droplets impact on surfaces exist widely in industrial equipments, such as spraying cooling, ink jet printing, oil drops impact on walls in combustion chamber, brine droplets impact on heat transfer tubes in horizontal-tube falling film evaporators etc. In particular, for the droplets impinging on heated surfaces, the contact scale and the heat transfer flux affect the cooling of the hot surfaces greatly. In this work, evaporation processes of water and ethanol droplets impact on a heated surface are observed using a high-speed digital camera with a capacity of 106 frames per second. The corresponding evaporation parameters including the contact diameter, the droplet height, the contact angle, and heat flux are analyzed. The initial liquid temperature keeps constant at 20 ℃, and the initial surface temperature varies in the range of 68-126 ℃. Diameters of single water droplets and ethanol droplets are 2.07 and 1.64 mm, respectively. The impact Weber number of water droplets ranges from 2 to 44 while that of ethanol droplets ranges from 3 to 88. The present results show that due to the coupled effects of gravity, surface tension, fluid flow and evaporation processes, the height of water droplets reduces continuously while the contact diameter almost does not change during the most part of evaporation time. In the later stage of evaporation, the contact diameter, height and contact angle of water droplets oscillate, mainly because of droplet retraction. The critical contact angle for water droplets retraction is in the range of 4-8. The contact angle of ethanol droplets first reduces and then remains constant, while the contact diameter and the height decrease continuously. The droplet evaporation time depends on liquid properties and the surface temperature, and the Weber number effect is minor. The evaporation time decreases with the increase in the surface temperature. At the same time, with increasing surface temperature, the ratio between the sensible heat and the total heat increases, and this part of heat cannot be neglected from the total heat transfer calculation. Based on the present experimental conditions, the average heat flux for the water droplets ranges from 0.014 to 0.110 Wmm-2 in this work.

Experimental Study on Water Droplet Evaporation Under the Incident Laser of 1985 nm

ICOPE-15-C064 Numerical Analysis of a Single Water Droplet Evaporation Caused by Laser Radiation

ICOPE-15-C063 Photoacoustic Effect in a Single Water Droplet Evaporation Excited by Laser : Analysis of Physical Processes

Ir Laser Caused Droplet Evaporation on the Hydrophobic Surface

Numerical Study of Nanosecond Pulsed Laser Impact on a Water Droplet

Critical laser frequency for nanofluid pendant droplet evaporation

Experimental Investigation of Dynamic Evaporation Characteristics of Liquid Droplet on Heated Surface

Cassie-to-Wenzel Transition of Droplet on the Superhydrophobic Surface Caused by Light Induced Evaporation

Ir Laser Induced Meniscus Evaporation from A Microchannel

IR laser assisted photothermal condensation in a microchannel

Time-Evolution of Laser-Induced Water Condensation

Droplet Evaporation to Boiling in Van Der Waals Fluid

Evaporation and wetting behavior of water on the laser-textured silicon substrate

Control of the droplet generation by an infrared laser

Experimental studies of droplet nucleate boiling characteristics on micro-cavities surfaces with different wettability

Experimental Study of Heat Transfer from Droplet Impact on A Heated Surface

Simulation on the Dynamic Flow and Heat and Mass Transfer of a Liquid Column Induced by the IR Laser Photothermal Effect Actuated Evaporation in a Microchannel

Numerical Investigation of Evaporation and Radiation Absorption of a Non-Spherical Water Droplet under Asymmetrically Radiative Heating

Numerical Investigation of the Marangoni Convection During the Liquid Column Evaporation in Microchannels Caused by Ir Laser Heating

An Experimental Investigation on Spreading of Droplets with Evaporation and Nucleation

Heat Transfer and Thermocapillary Flow of a Double-Emulsion Droplet Heated Using an Infrared Laser by the Photothermal Effect: a Numerical Study