Abstract:Permeability of nonsaline cap rock and interlayers is a key parameter for the assessment of the tightness of gas storage caverns in bedded salt formations. X-ray Diffraction, permeability tests, Scanning Electron Microscope studies and theoretical analyses have been performed for the mudstone cap rock and interlayers of a potential cavern in a bedded salt formation. The results show that the permeability of cap rock and interlayers is in the range of 10−18–10−20m2, whereas the interface in between salt and interlayer behaves as if impervious. Applied confinement conditions significantly affect the permeability. The higher the applied hydrostatic pressure, the lower the permeability. Permeability decreases more than one order of magnitude with hydrostatic pressure increases, up to a certain “compression threshold pressure”. Permeability remains virtually constant, at an extremely low magnitude, once the hydrostatic pressure exceeds this “compression threshold pressure”. The intrinsic reasons for the low permeability have been revealed by SEM studies, and are as follows: (1) the grains making up the bulk of the mudstone are very small and extremely tightly cemented; secondary minute clay minerals completely fill the pores and fissures between grains of quarts and feldspar, etc., resulting in very little residual void space and reducing connectivity for fluid penetration; and (2) the boundaries between quartz, feldspar and other grains are mainly plate-shape cracks that are poorly interconnected while the finer matrix is very tight and crack-free. The mechanical compaction investigation shows that the plate-shape cracks are much easier to be compacted than sphere-shape pores, which contributes significantly to the decrease in permeability. A capillary tube model suggests that permeability decreases very rapidly in the initial stages of compaction, but decreases extremely slowly in subsequent stages. So the permeability obviously behaves differently before and after the “compression threshold pressure”. By comparison with previous studies, the research we launched demonstrates that the cap rock and interlayers are characterized by extremely low permeability in compression regions. Hence the requirements of tightness (except for the possible presence of Excavation Disturbed Zones) are basically guaranteed. Also, a recommendation is expressed as: to ensure higher tightness and safety, reasonable design and operating programs should be adopted to reduce the EDZs as much as possible.

RESEARCH ON GAS SEEPAGE LAW IN LAMINATED SALT ROCK GAS STORAGE

Numerical Simulation of Gas Leakage in Bedded Salt Rock Storage Cavern

Study on the long-term airtightness of salt cavern gas storage considering the permeability variation of surrounding rock

Study on Sealing Failure of Wellbore in Bedded Salt Cavern Gas Storage

Permeability characteristics of mudstone cap rock and interlayers in bedded salt formations and tightness assessment for underground gas storage caverns

Study on gas leakage along cement sheath interfaces in salt cavern gas storage well

Gas transport model in pore heterogeneous bedded salt rock: Implications for tightness evaluation of salt cavern gas storage

Tightness and stability evaluation of salt cavern underground storage with a new fluid–solid coupling seepage model

Gas seepage around bedded salt cavern gas storage

Investigation on the permeability characteristics of bedded salt rocks and the tightness of natural gas caverns in such formations

Influence mechanism of brine-gas two-phase flow on sealing property of anisotropic caprock for hydrogen and carbon energy underground storage

Analysis of Damage and Permeability Evolution of Sandstone under Compression Deformation

RESEARCH ON CREEP PARAMETERS OPTIMIZATION OF SALT BED IN DEEP GAS STORAGE GROUP

Failure Patterns in Layered Gas-Storage Systems

Comprehensive Research on Construction and Stability of Horizontal-Well Cavity Natural Gas Storage in Thinly Bedded Salt Rocks in China

Gas injection and brine discharge in rock salt gas storage studied via numerical simulation

Stability and tightness evaluation of bedded rock salt formations for underground gas/oil storage

Experimental Study on the Evolution Law of Breakthrough Pressure of Mudstone Cap under Alternating Load

Experimental study on the permeability evolution mechanism of fractured coal-rock combination under ground stress and gas pressure

Stability evaluation of underground gas storage salt caverns with micro-leakage interlayer in bedded rock salt of Jintan, China

Stability Analysis of a Typical Salt Cavern Gas Storage in the Jintan Area of China