Abstract:Permeability of nonsaline cap rock and interlayers is a key parameter for the assessment of the tightness of gas storage caverns in bedded salt formations. X-ray Diffraction, permeability tests, Scanning Electron Microscope studies and theoretical analyses have been performed for the mudstone cap rock and interlayers of a potential cavern in a bedded salt formation. The results show that the permeability of cap rock and interlayers is in the range of 10−18–10−20m2, whereas the interface in between salt and interlayer behaves as if impervious. Applied confinement conditions significantly affect the permeability. The higher the applied hydrostatic pressure, the lower the permeability. Permeability decreases more than one order of magnitude with hydrostatic pressure increases, up to a certain “compression threshold pressure”. Permeability remains virtually constant, at an extremely low magnitude, once the hydrostatic pressure exceeds this “compression threshold pressure”. The intrinsic reasons for the low permeability have been revealed by SEM studies, and are as follows: (1) the grains making up the bulk of the mudstone are very small and extremely tightly cemented; secondary minute clay minerals completely fill the pores and fissures between grains of quarts and feldspar, etc., resulting in very little residual void space and reducing connectivity for fluid penetration; and (2) the boundaries between quartz, feldspar and other grains are mainly plate-shape cracks that are poorly interconnected while the finer matrix is very tight and crack-free. The mechanical compaction investigation shows that the plate-shape cracks are much easier to be compacted than sphere-shape pores, which contributes significantly to the decrease in permeability. A capillary tube model suggests that permeability decreases very rapidly in the initial stages of compaction, but decreases extremely slowly in subsequent stages. So the permeability obviously behaves differently before and after the “compression threshold pressure”. By comparison with previous studies, the research we launched demonstrates that the cap rock and interlayers are characterized by extremely low permeability in compression regions. Hence the requirements of tightness (except for the possible presence of Excavation Disturbed Zones) are basically guaranteed. Also, a recommendation is expressed as: to ensure higher tightness and safety, reasonable design and operating programs should be adopted to reduce the EDZs as much as possible.

Study on the long-term airtightness of salt cavern gas storage considering the permeability variation of surrounding rock

Tightness and stability evaluation of salt cavern underground storage with a new fluid–solid coupling seepage model

Numerical Simulation of Gas Leakage in Bedded Salt Rock Storage Cavern

Gas seepage around bedded salt cavern gas storage

Gas transport model in pore heterogeneous bedded salt rock: Implications for tightness evaluation of salt cavern gas storage

EXPERIMENTAL STUDY OF PERMEABILITY OF SALT ROCK AND ITS APPLICATION TO DEEP UNDERGROUND GAS STORAGE

Study on gas leakage along cement sheath interfaces in salt cavern gas storage well

RESEARCH ON GAS SEEPAGE LAW IN LAMINATED SALT ROCK GAS STORAGE

Permeability characteristics of mudstone cap rock and interlayers in bedded salt formations and tightness assessment for underground gas storage caverns

Research on Gas Leakage and Collapse in the Cavern Roof of Underground Natural Gas Storage in Thinly Bedded Salt Rocks

Long-term stability analysis and evaluation of horizontal salt cavern gas storage

Tightness Analysis of Underground Natural Gas and Oil Storage Caverns With Limit Pillar Widths in Bedded Rock Salt

Study on Sealing Failure of Wellbore in Bedded Salt Cavern Gas Storage

Study on visco-elastoplastic fractional creep model of surrounding rock of salt cavern gas storage

Stability Analysis of a Typical Salt Cavern Gas Storage in the Jintan Area of China

Experimental and Molecular Dynamics Studies on the Multiscale Permeability Properties of Various Gases in Salt Rock

Tightness and Suitability Evaluation of Abandoned Salt Caverns Served As Hydrocarbon Energies Storage under Adverse Geological Conditions (Agc)

Geomechanical Feasibility Analysis of Salt Cavern Gas Storage Construction in Sanshui Basin, Guangdong Province

Time-dependent subsidence prediction model and influence factor analysis for underground gas storages in bedded salt formations

Safety evaluation of salt cavern gas storage close to an old cavern