Release Characteristics of Gaseous Products During Rapid Pyrolysis of Upgraded Lignite
Xiangbo Zou,Zhihua Wang,Xin Hu,Zhijun Zhou,Zhenyu Huang,Junhu Zhou,Kefa Cen
DOI: https://doi.org/10.11715/rskxjs201303012
2013-01-01
Abstract:First of all, three kinds of low rank coal were dewatered and upgraded by hydrothermal treatment under high temperature and high pressure conditions. The experimental results show that hydrothermal treatment can effectively decrease the inherent water in coal, volatile and oxygen content, increase the fixed carbon content and heating value, and eventually elevate lignite rank gradually. Then, rapid pyrolysis experiments were carried out in a CDS-5000 Pyroprobe at 5000°C/s, 1000°C, which investigated the relationship between final reaction temperature and the production and volume fraction of H2, CO, CH4 and CO2 in the pyrolysis gas, as well as the heating value of pyrolysis gas. As the final reaction temperature climbs, it is found that the production of H2, CO, CO2 is reduced for each kind of coal, while the production of CH4 increases. Besides, CO and CO2 are the main components of the pyrolysis gas, while the contents of H2 and CH4 are much lower. The change of pyrolysis gas composition content with final reaction temperature shows good regularity. CO and CH4 contents rise, while H2 and CO2 contents show an opposite trend. And the upward trend of CO content is not obvious, however, CH4 content is dramatically increased. Also, the heating value of pyrolysis gas goes up constantly with the increase of the final reaction temperature. The heating value of BRXL is similar to that of YM, and that of ZD is the lowest.