Abstract:The treatment of nanoparticle (NP) polluted aqueous suspensions by flotation can be problematic due to the low probability of collision between particles and bubbles. To overcome this limitation, the present work focuses on developing an enhanced flotation technique using the surface-functionalized micro-bubbles - colloidal gas aphrons (CGAs). The CGA generator was adapted to be air flow rate controlled based on the classical Sebba system; thus it could be well adopted in a continuous flotation process. Cetyl trimethylammonium bromide (CTAB) and sodium dodecyl sulfate (SDS) were employed for CGA creation. Positively surface-charged CTAB-CGAs (similar to 44.1 mu m in size) and negatively surface-charged SDS-CGAs (similar to 42.1 mu m in size) were produced at the optimum stirring speed of 8000 rpm. The half-life of CGAs varied from 100 s to 340 s under the tested conditions, which was largely sufficient for transferring CGAs from bubble generator to flotation cell. The air flow led to less stable CTAB-CGAs but apparently enhanced the stability of SDS-CGAs at higher air flow rates. In the presence of air flow, the drainage behavior was not much related to the type of surfactants. The continuous CGA-flotation trials highlighted the effective separation of silica nanoparticles - the removal efficiencies of different types of SiO2 NPs could reach approximately 90%-99%; however, at equivalent surfactant concentrations, no greater than 58% of NPs were removed when surfactants and bubbles were separately added into the flotation cell. The SiO2 NPs with small size were removed more efficiently by the CGA-flotation process. For the flotation with CTAB-CGAs, the neutral and basic initial SNP suspension was recommended, whereas the SDS-CGAs remained high flotation efficiency over all investigated pH. The good performance of CGA-flotation might be interpreted: most of the surfactant molecules well covered/coated on the surfaces of stable CGAs and thus fully contacted with NPs, resulting in the efficient utilization of surfactants. (C) 2017 Elsevier Ltd. All rights reserved.

Harvesting Microalgal Cells by Dissolved Air Flotation under Low Saturation Pressures

Harvesting Microalgal Cells by Dissolved Air Flotation

Harvesting Spirulina Cells by Foam Flotation Technique on a Laboratory Scale

Flocculation Effect of Alkaline Electrolyzed Water (AEW) on Harvesting of Marine Microalga Tetraselmis sp.

Application of microbubble air flotation to harvest Microcystis sp. from agriculture wastewater: The regulation and mechanisms

Surface-modified Microbubbles (colloidal Gas Aphrons) for Nanoparticle Removal in a Continuous Bubble Generation-Flotation Separation System.

The Biophysical Properties of Microalgal Cell Surfaces Govern Their Interactions with an Amphiphilic Chitosan Derivative Used for Flocculation and Flotation

Electro-flotation of Chlorella Sp. Assisted with Flocculation by Chitosan

Harvesting optimization and Omega-3 recovery improvement from Schizochytrium DT3 using surfactant-aided dispersed air flotation: Response surface methodology

Study on the cell-collector-bubble interfacial interactions during microalgae harvesting using foam flotation

Improving electrocoagulation floatation for harvesting microalgae

An Efficient Microalgal Biomass Harvesting Method with a High Concentration Ratio Using the Polymer-Surfactant Aggregates Process

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

A multi-dimensional comparative study on the performance of algae removal using various flotation

Algae Separation from Urban Landscape Water Using a High Density Microbubble Layer Enhanced by Micro-Flocculation.

Freshwater microalgae harvested via flocculation induced by pH decrease

Uncovering the optimal structural characteristics of flocs for microalgae flotation using Python-OpenCV

HARVESTING SPIRULINA CELLS BY CONTINUOUS FOAM SEPARATION

Performance and Working Mechanism of a Novel Anaerobic Self-Flotation Reactor for Treating Wastewater with High Suspended Solids

Harvesting of Microcystis flos-aquae using dissolved air flotation: The inhibitory effect of carboxyl groups in uronic acid-containing carbohydrates

Efficiency and mechanism of ozonated microbubbles for enhancing the removal of algae and algae-derived organic matter