Abstract:Abstract Background Recent studies have demonstrated that microalga has been widely regarded as one of the most promising raw materials of biofuels. However, lack of an economical, efficient and convenient method to harvest microalgae is a bottleneck to boost their full-scale application. Many methods of harvesting microalgae, including mechanical, electrical, biological and chemical based, have been studied to overcome this hurdle. Results A new flocculation method induced by decreasing pH value of growth medium was developed for harvesting freshwater microalgae. The flocculation efficiencies were as high as 90% for Chlorococcum nivale , Chlorococcum ellipsoideum and Scenedesmus sp. with high biomass concentrations (>1g/L). The optimum flocculation efficiency was achieved at pH 4.0 . The flocculation mechanism could be that the carboxylate ions of organic matters adhering on microalgal cells accepted protons when pH decreases and the negative charges were neutralized, resulting in disruption of the dispersing stability of cells and subsequent flocculation of cells. A linear correlation between biomass concentration and acid dosage was observed. Furthermore, viability of flocculated cells was determined by Evans Blue assay and few cells were found to be damaged with pH decrease. After neutralizing pH and adding nutrients to the flocculated medium, microalgae were proved to maintain a similar growth yield in the flocculated medium comparing with that in the fresh medium. The recycling of medium could contribute to the economical production from algae to biodiesel. Conclusions The study provided an economical, efficient and convenient method to harvest fresh microalgae. Advantages include capability of treating high cell biomass concentrations (>1g/L), excellent flocculation efficiencies (≥ 90%), operational simplicity, low cost and recycling of medium. It has shown the potential to overcome the hurdle of harvesting microalgae to promote full-scale application to biofuels from microalgae.

Harvesting Spirulina Cells by Foam Flotation Technique on a Laboratory Scale

HARVESTING SPIRULINA CELLS BY CONTINUOUS FOAM SEPARATION

Harvesting Microalgal Cells by Dissolved Air Flotation

Harvesting Microalgal Cells by Dissolved Air Flotation under Low Saturation Pressures

Flocculation Effect of Alkaline Electrolyzed Water (AEW) on Harvesting of Marine Microalga Tetraselmis sp.

Electro-flotation of Chlorella Sp. Assisted with Flocculation by Chitosan

Study on the cell-collector-bubble interfacial interactions during microalgae harvesting using foam flotation

An Efficient Microalgal Biomass Harvesting Method with a High Concentration Ratio Using the Polymer-Surfactant Aggregates Process

Application of microbubble air flotation to harvest Microcystis sp. from agriculture wastewater: The regulation and mechanisms

Harvesting optimization and Omega-3 recovery improvement from Schizochytrium DT3 using surfactant-aided dispersed air flotation: Response surface methodology

The Biophysical Properties of Microalgal Cell Surfaces Govern Their Interactions with an Amphiphilic Chitosan Derivative Used for Flocculation and Flotation

Efficient Harvesting of Green Microalgae Cells by Magnetic Flocculated Fe3O4 Nanoparticles Combined with Chitosan

Effect mechanism of metal cations on the interface interaction of cell-collector-bubble for microalgal foam flotation

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Application and Development of Separation and Enrichment Technique for Floatation in Analytical Chemistry

Improving electrocoagulation floatation for harvesting microalgae

Study on the Harvest of Oleaginous Microalgae Chlorella Sp. by Photosynthetic Hydrogen Mediated Auto-Flotation for Biodiesel Production

Research on the influence of aeration manners on the mass transfer characteristics of bubbles in multi‐column airlift photobioreactor

Freshwater microalgae harvested via flocculation induced by pH decrease

A comparative study between fungal pellet- and spore-assisted microalgae harvesting methods for algae bioflocculation.

Studies on Developments of Microspheres from Macroalgal Clones and Cultivations in Airlift Photobioreactor