Abstract:The sustainability of an agricultural system depends highly upon the recycling of all useful substances from agricultural wastes. This study explored the feasibility of comprehensive utilization of C, N and P resources in swine manure (SM) through short-term dry anaerobic digestion (AD) followed by dry ammonia stripping, aiming at achieving (1) effective total volatile fatty acids (VFAs) production and separation; (2) ammonia recovery from the digestate; and (3) preservation of high P bioavailability in the solid residue for further applications. Specifically, two ammonia stripping strategies were applied and compared in this work: (I) ammonia stripping was directly performed with the digestate from dry AD of SM (i.e. dry ammonia stripping); and (II) wet ammonia stripping was conducted by using the resultant filtrate from solid-liquid separation of the mixture of digestate and added water. Results showed that dry AD of the tested SM at 55 degrees C, 20% TS and unadjusted initial pH (8.6) for 8 days produced relatively high concentrations of total VFAs (94.4 mg-COD/g-VS) and ammonia-N (20.0 mg/g-VS) with high potentially bioavailable P (10.6 mg/g-TS) remained in the digestate, which was considered optimal in this study. In addition, high ammonia removal efficiencies of 96.2% and 99.7% were achieved through 3 h' dry and wet stripping (at 55 degrees C and initial pH 11.0), respectively, while the total VFAs concentration in the digestate/filtrate remained favorably unchanged. All experimental data from the two stripping processes well fitted to the pseudo first -order kinetic model (R-2 = 0.9916-0.9997) with comparable theoretical maximum ammonia removal efficiencies (A(eq), >90%) being obtained under the tested dry and wet stripping conditions, implying that the former was more advantageous due to its much higher volumetric total ammonia-N removal rate thus much smaller reactor volume, less energy/chemicals consumption and no foaming problems. After 8 days' dry AD and 3 h' dry ammonia stripping, the separated liquid containing VFAs and the recovered ammonia were both marketable products, and the solid residues with averagely higher C/N ratios of 25.7 than those of raw SM (18.0) meanwhile maintaining a relatively high bioavailable P content of 8.1 mg/g-TS can serve as better feedstock for methane fermentation. (C) 2015 Elsevier Ltd. All rights reserved.

Acidification Characteristics of Two-phase Anaerobic Fermentation by Separated Liquids from Dairy Manure with Swine

Two-phase Anaerobic Co-Digestion of Dairy Manure with Swine Manure

Technology for two-phase anaerobic fermentation by solid-liquid separated solution of dairy manure

Research on the Two-phase Anaerobic Fermentation of Livestock Dung

Influence of Digested Liquid Composition on Solid Waste Anaerobic Hydrolysis

Effect of Alkaline Treatment Pattern on Anaerobic Fermentation of Swine Manure

Optimization of Hydrolysis-Acidogenesis Phase of Swine Manure for Biogas Production Using Two-Stage Anaerobic Fermentation

Effect of Dosing Rate on Continuous Two-Phase Anaerobic Fermentation Acidification Process

Hydrogen–methane Production from Swine Manure: Effect of Pretreatment and VFAs Accumulation on Gas Yield

The Production of Short-Chain Fatty Acids and Constituents with Primary Sludge As Fermentation Substrate under Different Phs

The Anaerobic Fermentation Characterization of the Dairy Manure

Comparison of One-Phase and Two-Phase Anaerobic Digestion of Swine Manure

Effect of Anaerobic Fermentation of Dairy and Pig Manure’ s Solid-liquid Separation

Two-phase Anaerobic Digestion of Lignocellulosic Hydrolysate: Focusing on the Acidification with Different Inoculum to Substrate Ratios and Inoculum Sources.

Continuous Production of Volatile Fatty Acids (vfas) from Swine Manure: Determination of Process Conditions, VFAs Composition Distribution and Fermentation Broth Availability Analysis

Effect of Initial Ph on Mesophilic Hydrolysis and Acidification of Swine Manure

Hydrolysis and Acidification of Agricultural Waste in a Non-Airtight System: Effect of Solid Content, Temperature, and Mixing Mode.

Effect of low intensity air-stirring on solid acidogenic digestion with pig manure and straw as feedstock

Microorganism Population in Two-Phase Anaerobic Fermentation of Separated Liquid of Dairy Manure

Volatile Fatty Acids (vfas) Production from Swine Manure Through Short-Term Dry Anaerobic Digestion and Its Separation from Nitrogen and Phosphorus Resources in the Digestate

Anaerobic Co-digestion of Rice Straw and Swine Feces