Effect of substrate dilution ratio combined with ultrasonic irradiation on acidification of bean dregs anaerobic fermentation
Zou Yongjie,Chen Ling,Jiang Weizhong,Wu Xinyan,Yang Jin
DOI: https://doi.org/10.11975/j.issn.1002-6819.2017.06.027
2017-01-01
Abstract:Anaerobic digestion has been applied widely used in treatment of municipal solid wastes due to its advantages of energy recovery and environmental protection. However, in the case of particle-substrate digestion, the acidification products were prone to accumulate, which inhibited not only methanogenesis, but also hydrolysis and acidification. In order to alleviate the acid inhibition during acidification of solid organic wastes, ultrasonic irradiation was introduced to destroy the product-films and promote the acidification performance. The previous study demonstrated that direct ultrasonic irradiation could desorbed VA from particle surfaces, and elevated the VS degradation rate from 0.8% to 1.3% per day. The volatile acid increasing ratio and VS degradation ratio were increased from 166.7% to 732.0%, and 17.0% to 26.7%, respectively, by the modified ultrasonic treatment (3-times dilution, 20 min ultrasonic irradiation filtration). However, ultrasonic wave energy intensity would be attenuated during its propagation in the medium, so at the same ultrasonic frequency, the higher the medium concentration was, the greater the intensity attenuation. The substrate concentrations of solid wastes during the ultrasonic irradiation would have a role on treatment effect and equipment requirements. The selection of substrate concentration should not only combine with the VA removal rate and the fermentation performance, but also the fermentation device volume and water consumption. In this study, the effects of substrate concentration during ultrasonic treatment on the fermentation properties were investigated. Fermentation broth from previous acidification (volatile acid concentration was 18.8 g/L) was diluted by 1, 2, 3, 4, 5 and 6 times (to ensure consistent radiation areas, the total mass of the treated medium and the water in the container was always the same). After that they were imposed on ultrasonic irradiation for 20 minutes, and filtrated to the initial weight. The samples of treated broth were withdrawn to determine pH value, total solid (TS), volatile solid (VS), volatile acid (VA) concentration and particle size distribution. The results demonstrated that dilution combined with ultrasonic irradiation treatment played a key role to VA removal. Higher VA removal rate and smaller particle size was obtained by the treatment with higher dilution ratio. Considering that higher dilution ratio would result in more water consumption and bigger reactor volume, dilution ratio with 1, 2 and 3 times were chosen to next fermentation. The broth with ultrasonic irradiation and dilution ratio of 1, 2 and 3 times were fermented for 10 days in a rotational drum fermentation system. A control with untreated broth was also investigated. The experiments were set up in duplicate. The experiment results showed that the broth fermentation with higher dilution ratio got not only more VA production, but also rapid substrate degradation. On the other hand, due to the almost saturated VA removal, the improvement of fermentation performance with the broth diluted by 2 and 3 times was not obviously. Taking water consumption and reactor volume into account, the conditions of the diluted fermentation broth 46 g/L, ultrasonic irradiation 20 min and filtration were more suitable to promote the acidification of solid organic wastes when their VA concentrations were between 10 and 20 g/L.