Abstract:Enzyme-assisted aqueous extraction processing (EAEP) has long been considered as a promising alternative to traditional solvent oil extraction,which has gained increasing attention recently.After EAEP of soybeans,three distinct layers are formed:cream,skim and residual fraction.The skim fraction contains substantial amount of protein as well as oil,sugar and other impurities.In order to recover value from this liquid fraction,ultrafiltration was employed for protein concentration and isolation.To investigate the interrelationship between operating parameters and membrane flux,BoxBehnken response surface methodology was introduced.The results indicated that the three factors'effects on membrane flux followed the decreasing order as:solution mass fraction,transmembrane pressure and solution pH value.The improved regression model was fitted with determination coefficient of 0.997 5 and optimal factors were as follows:operative pressure of 0.20 MPa,solution mass fraction of 5.60％,and solution pH value of 8.50.The permeate flux under above conditions was 7.02 L/(m2·h) and protein purity was increased to 88.63％.The infrared spectrum and HPLC analysis showed evidently characteristic peaks of functional groups in soybean protein and remarkable low levels of undigestible oligosaccharides.Besides,the protein extracted from EAEP showed improved solubilities especially at acidic pH value,but it slightly decreased emulsifying activity index and emulsifying stability index.Further improvement can be achieved if industrial fractionation unit was employed and process optimization was conducted.A complete cost-effectiveness analysis would also need to be done to estimate the economic viability of this application.

Soy protein wastewater treatment and resource reclamation with ultrafiltration

Performance of Ultrafiltration Membrane Technology in Treatment of Soy Whey Wastewater

Investigation Of Microfiltration For Pretreatment Of Whey Concentration

APPLICATION OF UF/NF IN RESOURCE RECLAMATION OF SOYBEAN WHEY

Study on ultrafiltration membrane properties by the soy protein wastewater

Treatment of Soybean Whey with Dual-Step Ultrafiltration System

Pilot Study on the Treatment of Soybean Whey with Air Blasting Enhanced Vibratory Ultrafiltration

Recovery of Soybean Whey Protein by Ultrafiltration Pretreatment

Application of Ultrafiltration on Separation and Purification of Soybean Peptides

Pretreatment Research of Soy Whey

Optimization of Protein Removal from Soybean Whey Wastewater Using Chitosan Ultrafiltration

Pilot Study on the Treatment of Ultrafiltration for Laundry Wastewater Recycling and Reuse

STUDY ON TREATMENT OF PRODUCTION WASTEWATER OF RECYCLE PAPER BY POLYSULFONE ULTRAFILTRATION MEMBRANE

Utilization of Ultrafiltration Technology in the Treatment of Sweet Potato Starch Production Wastewater

Study on ultrafiltration for surface water by a polyvinylchloride hollow fiber membrane

Ultrafiltration membranes prepared via mixed solvent phase separation with enhanced performance for produced water treatment

Try to Pretreat Organic Waste Water with High Concentration of Acid and Salt and Membrane Fouling

Recovery of high value-added protein from enzyme-assisted aqueous extraction (EAE) of soybeans by dead-end ultrafiltration.

Ultrafiltration Recovery of Skim Protein from Enzyme-assisted Aqueous Extraction Process of Soybean and Its Functional Properties

Purification of Soybean Isoflavones from Soy Sauce Residue by Ultrafiltration

Preparation and Characterization of Low MWCO PES/SPSF Blend Ultrafiltration Membrane