Abstract:Monitoring the presence of nanoparticles in dispersions having broad particle size distributions can be a problem for many measurement techniques because large particles or even aggregates of the smaller particles can mask the presence of the sought after nanoparticles. The ability of many existing techniques to detect the nanoparticles when present in broad polydisperse systems is largely unknown, yet it is critical for proper selection of the measuring technique for characterizing a particular nanodispersion. Acoustic spectroscopy is already a known and proven tool for studying nanoparticles in systems with a narrow size distribution. The purpose of this paper is to evaluate the sensitivity of acoustic spectroscopy for determining the nanoparticle content of very polydisperse systems. We used eight different ZnO powders from different manufacturers to prepare 5wt.% dispersions, each dispersed in water. The stability of each dispersion was optimized by pH adjustment and addition of sodium hexametaphosphate as determined by maximizing the measured zeta-potential. According to the acoustic measurement, the median size of these different ZnO dispersions varied from 200nm to 700nm. Independent TEM photographs in general confirmed the size variation between the samples. Independent DLS measurements failed to provide particle size data correlating with TEM. The acoustic measurements further showed that each dispersion contained a different relative content in the nanoparticle fraction. The precision with which the nanoparticle fraction could be determined was better than 2% of the total solid loading for all samples. In order to verify consistency of this measurement we performed a mixing study by adding dispersion with the largest nanoparticle content to the dispersion with the smallest nanoparticle content, in small increments. This test confirms that the acoustic sensitivity threshold is about 2% of nanoparticles in the broad polydisperse dispersions of dense metal oxide particles.

Acoustic agglomeration experiments of monodispersed aerosol

Interaction between Strong Sound Waves and Aerosol Droplets: Numerical Simulation

Inter-Particle Effects with a Large Population in Acoustofluidics

Preliminary Experimental Study of Acoustic Agglomeration of Coal-Fired Fine Particles

Numerical Simulation of Acoustic Wake Effect in Acoustic Agglomeration under Oseen Flow Condition

Numerical Study of Acoustic Agglomeration Process of Droplet Aerosol Using a Three-Dimensional CFD-DEM Coupled Model

Theoretical Study of Acoustic Wake Effect in Acoustic Agglomeration

Acoustic agglomeration of coal-fired fly ash particles in low frequency sound fields

Theoretical Analysis of Acoustic and Turbulent Agglomeration of Droplet Aerosols

Investigation of Critical Response Characteristics of Micro-Droplets under the Action of Low-Frequency Acoustic Waves

Determination of Particle Size Distribution by Multi-Scale Analysis of Acoustic Emission Signals in Gas-Solid Fluidized Bed

Improving agglomeration efficiency of aerosols with sizes less than 2.5 µm by generation of vortex streams in inhomogeneous ultrasonic field

Experimental Study of Acoustic Agglomeration of Coal-Fired Fly Ash Particles at Low Frequencies

Micro-droplet Deposition and Growth on a Glass Slide Driven by Acoustic Agglomeration

Monitoring nanoparticles in the presence of larger particles in liquids using acoustics and electron microscopy

Experimental study on improving the efficiency of dust removers by using acoustic agglomeration as pretreatment

The Influences of Acoustic and Pulsed Corona Discharge Coupling Field on Agglomeration of Monodisperse Fine Particles

REVIEW AND PROSPECT OF ACOUSTIC WAVE AGGLOMERATION TECHNOLOGY FOR AEROSOL FINE PARTICLES

Ultrasonic Aerosol Agglomeration: Manipulation of Particle Deposition and Its Impact on Air Filter Pressure Drop

Review of Acoustic Agglomeration Technology Research

Microphysical Characteristics and Environmental Isotope Effects of the Micro-Droplet Groups under the Action of Acoustic Waves